Manuals / Sears / Lawn and Garden / Lawn Mower

Sears 917.25271 Assem Bly, Tools Required For Assembly, To Remove Tractor From Carton, Fig

Models: 917.25271

1 120

Download 120 pages 4.39 Kb

Page 67

Manual background

INI

...... ASSEM BLY

iii

i ii

i

IIHIII

I

I

I

I I

II

II[llllll

Your new tractor has been assembled at the factory with exception of those parts left unassembled for shipping purposes. To ensure safe and proper operation of your tractor, all parts and hardware you assemble must be tightened securely. Use the correct tools as necessary to insure proper tightness.

....

'

_

i¸.2¸¸

TOOLS REQUIRED FOR ASSEMBLY

A socket wrench set will make assembly easier. Standard wrench sizes are listed.

(1)	9/16" wrench	(2)	7/16"	wrench
(1)	1/2" wrench	(1)	3/4"	socket w/drive
Utility knife			ratchet
Tire	pressure gauge	(1)	Phillips Screwdriver

When right and left hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel).

	STEERING	WHEEL
_	INSERT
	LOCKNUT
t	LARGE	FLAT
_	WASHER
'	STEERING WHEEL

TO REMOVE TRACTOR FROM CARTON

UNPACK CARTON

•Remove all accessible loose parts and parts cartons from carton (See page 6).

•Cut, from top to bottom, along lines on all four corners of carton, and lay panels flat.

•Check for any additional loose parts or cartons and remove.

BEFORE ROLLING TRACTOR OFF SKID

ATTACH STEERING WHEEL (See Fig. 1)

•Remove Iocknut and large flat washer from steering shaft.

•Position front wheels of the tractor so they are pointing straight forward.

•Slide the steering sleeve over the steering shaft.

•Position steering wheel so cross bars are horizontal (left to right) and slide onto adapter.

•Secure steering wheel to steering shaft with Iocknut and large flat washer previously removed. Tighten securely.

•Snap steering wheel insert into center of steering wheel.

•Remove protective plastic from tractor hood and grill.

IMPORTANT: CHECK FOR AND REMOVE ANY STAPLES IN SKID THAT MAY PUNCTURE TIRES WHERE TRACTOR IS TO ROLL OFF SKID.

STEERING

STEERING

ADAPTER

WHEEL _

.7 =

STEERING_;

SLEEVE....

FIG. 1

TO ROLL TRACTOR OFF SKID (See Fig. 8)

•Raise attachment lift lever to its highest position'.

•Release parking brake by depressing Clutch/brake pedal.

•Place freewheel control in freewheeling position to disengage transmission (See "TO TRANSPORT' in Operation section of this manual).

•Roll tractor backwards off skid.

•Remove banding holding discharge guard up against tractor.

7

Image 67

Sears 917.25271 Assem Bly, Tools Required For Assembly, To Remove Tractor From Carton, Before Rolling Tractor Off Skid

Contents

•Service and Adjustments •Repair Parts •Assembly •Operation •Customer ResponsibilitiesMODEL NUMBER 917.252710 OWNERS MANUAL transporting, adjusting or making repairs SAFETY RULESSAFETY IS INVOLVED accidental starting when setting upCUSTOMER RESPONSIBILITIES MAINTENANCE AGREEMENTPRODUCT SPECIFICATIONS LIMITED 90 DAY WARRANTY ON BATTERYWARRANTY CONTENTSSAFETY RULES SPECIFICATIONSENGINE ACCESSORIESMAINTENANCE AND ATTACHMENTSHARDWARE PACK CONTENTS OFParts Bag contents shown full size Parts bag contents not shown full sizeBEFORE ROLLING TRACTOR OFF SKID TOOLS REQUIRED FOR ASSEMBLYASSEM BLY TO REMOVE TRACTOR FROM CARTONINSTALL SEAT See Fig. ASSEMBLYHOW TO SET UP YOUR TRACTOR PREPARE BATTERY See Figs. 2A and 2BCHECK DECK LEVELNESS INSTALL BATTERY See Figs. 4 andCAUTION: Do not short battery termi CHECK TIRE PRESSURETO CONVERT TO BAGGING OR DISCHARGING CHECKLISTINSTALL MULCHER PLATE See Figs. 7A & 7B guard when attaching mulcher plateKNOW YOUR TRACTOR LIGHT SWITCH: Turns the headlights on and offCHOKE CONTROL: Used when starting a cold engine OPERATIONTO SET PARKING BRAKE See Fig. HOW TO USE YOUR TRACTORTO ADJUST MOWER CUTTING HEIGHT See Fig. See Fig.TO TRANSPORT See Figs. 8 and BEFORE STARTING THE ENGINEPUSHINTO _\ TO OPERATE MOWER See Fig.TO START ENGINE See Fig. fii AcAuieverenIioiiii.OPERATION ADD GASOLINEFIG. MOWING TIPSMULCHING MOWING TIPS OPERATIONCUSTOMER CHARTSE.V.C O TESTRACTOR BATTERY See Fig.CUSTOMER RESPONSIBILITIES GRADE8TRANSAXLE PUMP FLUID CLEAN AIR SCREEN See Fig.ENGINE TRANSAXLE COOLINGSPARK PLUGS CLEANINGENGINE OIL FILTER MUFFLERPlace motion control lever in neutral N position SERVICE AND ADJUSTMENTSTO INSTALL MOWER See Fig. TO REMOVE MOWER See Fig.FIG. BOTH FRONT LINKS MUST BE EQUAL IN LENGTH AND ADJUSTMENTSSERVICE TO LEVEL MOWER HOUSINGTO REPLACE MOWER BLADE DRIVE BELT See Fig. SERVICE ANDADJUSTMENTS TO ADJUST BRAKE See Fig.TRANSMISSION REMOVAL/REPLACEMENT SERVICEADJUSTM TO ADJUST MOTION CONTROL LEVER See Fig.FRONT WHEEL TOE-IN/CAMBER SERVICE AND ADJUSTMENTSTO ADJUST STEERING WHEEL ALIGNMENT TO START ENGINE WITH A WEAK BATTERY See Fig.INTERLOCKS AND RELAYS TO REMOVE HOOD AND GRILL ASSEMBLY See Fig.•Raise hood •Unsnap headlight wire connector TO REPLACE HEADLIGHT BULBTO ADJUST CARBURETOR See Fig. SERVICE ANDADJUSTMENTS TO ADJUST THROTTLE CONTROL CABLE See Fig. 33 &FUEL SYSTEM BATTERYSTORAGE OTHERCORRECTION TROUBLESHOOTING POINTSPROBLEM CAUSECORRECTION TROUBLESHOOTING POINTSPROBLEM CAUSESERVICE NOTES NOTE IF WIRING INSULATED CLIPS WERE REMOVED FOR SCHEMATICSWITCH WIRING INSULATED CLIPS42 24 REPAIR PARTSTRACTOR -- MODEL NUMBER ELECTRICALELECTRICAL TRACTOR --MODEL NUMBERKEY PART NO. NO.DESCRIPTION REPAIR PARTSREPAIR PARTS CHASSIS AND ENCLOSURESTRACTOR - - MODEL NUMBER TRACTOR - - MODEL NUMBER PARTDESCRIPTION REPAIR PARTSREPAIR PARTS DRIVETRACTOR - - MODEL NUMBER DRIVE REPAIR PARTSKEY PART NO. NO TRACTOR - - MODEL NUMBERREPAIR PARTS STEERING ASSEMBLYTRACTOR - - MODEL NUMBER Nut, Hex, Fin. 3/8-24UNF Spindle Assembly, RHWasher 27/32 x 1-1/4x 16 Gauge Ring, Klip Bearing Link, Drag Washer, Lock7 35 1 38 14 130 2581 26 17 Spark ArresterOPTIONAL EQUIPMENT 43 4218ENGINE 8122439XREPAIR PARTS TRACTOR - - MODEL NUMBERTRACTOR --MODEL NUMBER SEAT ASSEMBLY_.--.-- REPAIR PARTSREPAIR PARTS DECALSWHEELS & TIRES Tire161718 2_ MOWER LIFT 28 26 23 7 8 41 37 38 404 6 6 4 12 13 19PART MOWER LIFTREPAIR PARTS TRACTOR -- MODEL NUMBER\ _J TRACTOR -- MODEL NUMBERMOWER DECK 75 74 73MOWER DECK 1 inch =REPAIR PARTS TRACTOR - - MODEL NUMBER58 90 53 52 40 68 3 6_ 69 62 14 4 3 24 36 HYDRO GEAR TRANSAXLE - MODEL NUMBERREPAIR PARTS TRACTOR - - MODEL NUMBERDESCRIPTION REPAIR PARTSPART PART17/_ _L,_ A,D,,_RUD,,IBREATHER AND VENT J 18 j13 €++14TRACTOR -- MODEL NUMBER REPAIR PARTSAIR INTAKE TRACTOR -- MODEL NUMBER CARBU RETOR J_34 _ 35 _--- REPAIR PARTSTRACTOR - - MODEL NUMBER REPAIR PARTSELECTRIC STARTER o-,IDIPSTICK CRANKSHAFTTRACTOR - - MODEL NUMBER Screw 1/4-20 x 5/8Gasket, Exhaust REPAIR PARTSSERVICE NOTES SERVICE NOTES SERVICE NOTES 15 MAX SIGHTING GUIDEONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL SIGHT AND HOLD THIS LEVEL WITH SKY LINE OR TREE18 HP TWIN CYLINDER ELECTRIC START IF YOU NEED REPAIR SERVICE OR PARTSOWNERS MANUAL MODEL NO.•Service and Adjustments •Repair Parts •Assembly •Operation •Customer ResponsibilitiesMODEL NUMBER 917.252710 OWNERS MANUAL transporting, adjusting or making repairs SAFETY RULESSAFETY IS INVOLVED accidental starting when setting upCUSTOMER RESPONSIBILITIES MAINTENANCE AGREEMENTPRODUCT SPECIFICATIONS LIMITED 90 DAY WARRANTY ON BATTERYWARRANTY CONTENTSSAFETY RULES SPECIFICATIONSENGINE ACCESSORIESMAINTENANCE AND ATTACHMENTSHARDWARE PACK CONTENTS OFParts Bag contents shown full size Parts bag contents not shown full sizeBEFORE ROLLING TRACTOR OFF SKID TOOLS REQUIRED FOR ASSEMBLYASSEM BLY TO REMOVE TRACTOR FROM CARTONINSTALL SEAT See Fig. ASSEMBLYHOW TO SET UP YOUR TRACTOR PREPARE BATTERY See Figs. 2A and 2BCHECK TIRE PRESSURE ASSEMBLYINSTALL BATTERY See Figs. 4 and CAUTION: Do not short battery termiguard when attaching mulcher plate ASSEMBLYCHECKLIST INSTALL MULCHER PLATE See Figs. 7A & 7BKNOW YOUR TRACTOR LIGHT SWITCH: Turns the headlights on and offCHOKE CONTROL: Used when starting a cold engine OPERATIONTO SET PARKING BRAKE See Fig. HOW TO USE YOUR TRACTORTO ADJUST MOWER CUTTING HEIGHT See Fig. See FigTO TRANSPORT See Figs. 8 and BEFORE STARTING THE ENGINEPUSHINTO _\ TO OPERATE MOWER See Fig.TO START ENGINE See Fig. fii AcAuieverenIioiiii.OPERATION ADD GASOLINEFIG. OPERATIONMOWING TIPS MULCHING MOWING TIPSCUSTOMER CHARTSE.V.C O TESTRACTOR BATTERY See Fig.CUSTOMER RESPONSIBILITIES GRADE8TRANSAXLE COOLING CLEAN AIR SCREEN See Fig.CUSTOMER RESPONSIBILITIES ENGINEMUFFLER CLEANINGCUSTOMER RESPONSIBILITIES ENGINE OIL FILTERPlace motion control lever in neutral N position SERVICE AND ADJUSTMENTSTO INSTALL MOWER See Fig. TO REMOVE MOWER See Fig.FIG. AND ADJUSTMENTSSERVICE TO LEVEL MOWER HOUSINGTO REPLACE MOWER BLADE DRIVE BELT See Fig. SERVICE ANDADJUSTMENTS TO ADJUST BRAKE See Fig.TRANSMISSION REMOVAL/REPLACEMENT SERVICEADJUSTM TO ADJUST MOTION CONTROL LEVER See FigSee Fig. SERVICE AND ADJUSTMENTSTO ADJUST STEERING WHEEL ALIGNMENT TO START ENGINE WITH A WEAK BATTERY See Fig.•Raise hood •Unsnap headlight wire connector SERVICE ANDADJUSTMENTS TO REMOVE HOOD AND GRILL ASSEMBLY See Fig.TO ADJUST CARBURETOR See Fig. SERVICE ANDADJUSTMENTS TO ADJUST THROTTLE CONTROL CABLE See Fig. 33 &ENGINE BATTERYSTORAGE TRACTORCORRECTION TROUBLESHOOTING POINTSPROBLEM CAUSECORRECTION TROUBLESHOOTING POINTSPROBLEM CAUSESERVICE NOTES NOTE IF WIRING INSULATED CLIPS WERE REMOVED FOR SCHEMATICSWITCH WIRING INSULATED CLIPS42 24 REPAIR PARTSTRACTOR -- MODEL NUMBER ELECTRICALKEY PART NO. NO.DESCRIPTION REPAIR PARTSTRACTOR --MODEL NUMBER ELECTRICALTRACTOR - - MODEL NUMBER REPAIR PARTSCHASSIS AND ENCLOSURES PART REPAIR PARTSTRACTOR - - MODEL NUMBER CHASSIS AND ENCLOSURESTRACTOR - - MODEL NUMBER REPAIR PARTSDRIVE KEY PART NO. NO REPAIR PARTSTRACTOR - - MODEL NUMBER DRIVE_--2__2222 REPAIR PARTSSTEERING ASSEMBLY TRACTOR - - MODEL NUMBERTRACTOR --MODEL NUMBER REPAIR PARTSSTEERING ASSEMBLY Spindle Assembly, RHOPTIONAL EQUIPMENT REPAIR PARTSTRACTOR - - MODEL NUMBER Spark ArresterKEY PART NO. NO REPAIR PARTSTRACTOR - - MODEL NUMBER ENGINE_.--.-- REPAIR PARTSSEAT ASSEMBLY TRACTOR --MODEL NUMBERWHEELS & TIRES REPAIR PARTSTRACTOR -- MODEL NUMBER DECALS4 6 6 REPAIR PARTSTRACTOR - - MODEL NUMBER MOWER LIFT 28 26 23 7 8 41 37 38 40PART REPAIR PARTSTRACTOR -- MODEL NUMBER MOWER LIFT75 74 73 REPAIR PARTSTRACTOR -- MODEL NUMBER MOWER DECKKEY PART NO. NO REPAIR PARTSTRACTOR - - MODEL NUMBER MOWER DECKTRACTOR - - MODEL NUMBER REPAIR PARTSHYDRO GEAR TRANSAXLE - MODEL NUMBER DESCRIPTION REPAIR PARTSPART PARTBREATHER AND VENT J 10 REPAIR PARTS_L,_ A,D,,_RUD,,I TRACTOR --MODEL NUMBERTRACTOR -- MODEL NUMBER REPAIR PARTS_34 _ 35 _--- REPAIR PARTSTRACTOR -- MODEL NUMBER CARBU RETOR JTRACTOR - - MODEL NUMBER REPAIR PARTSDIPSTICK REPAIR PARTSo-,I TRACTOR --MODEL NUMBERGasket, Exhaust REPAIR PARTSTRACTOR - - MODEL NUMBER Screw 1/4-20 x 5/8SERVICE NOTES SERVICE NOTES SERVICE NOTES 15 MAX SIGHTING GUIDEONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL SIGHT AND HOLD THIS LEVEL WITH SKY LINE OR TREE3 in One Convertible 42 MOWER IF YOU NEED REPAIR SERVICE OR PARTSMODEL NO. 18 HP TWIN CYLINDER ELECTRIC START