GENERATOR APPLICATION
WHAT IS A GENERATOR
A generator is basically a prime mover, typically a gasoline or diesel engine, coupled to an alternator to produce electricity. It is very useful as a substitute power source during power outages or as the primary source in remote locations where power is not available. Generators are essential for people such as contractors or farmers who are always in need of portable power. They are also very convenient for recreational use.
SELECTING A GENERATOR
AS SHOWN IN THE TABLE BELOW. DO NOT EXCEED THE TOTAL GENERATOR NAMEPLATE RATING. All generator units are equipped with a
AMPERAGE RATE TABLE
|
| NEMA |
|
Model |
|
| |
|
| 125V GFCI |
|
S2800 |
| 20 Amps |
|
|
|
|
|
| RECEPTACLE DETAILS | ||
Selecting the proper generator is important. A generator that is too small for your application will not run all of the equipment needed. A generator that is too large will cost more and if never used to its potential the money is wasted. The correct size generator is determined by totaling the wattage requirements of the items to be used simultaneously, determine additional starting wattage requirements and total these numbers. Select a generator with a continuous rating that exceeds this by about 20% to allow for expansion. See the table in the section titled “Generator Set Overload” for some wattage guidelines of common equipment.
RATED vs. SURGE WATTS
Rated, or continuous, watts are the watts an item needs as it is running.
Surge, or maximum, watts are the watts an item needs to start. This is typically
This information is typically provided on the manufacturer’s nameplate. If watts are not provided, it can be calculated using the formula: Watts=Amps x Volts.
EXTENSION CORDS
An extension cord should always be in good condition with no damage to the wires or sheathing. Never run an extension cord through water. The correct wire size for an extension cord can be determined from the table that follows.
Continuous | Minimum Cord Gauge (AWG) | ||
Load |
|
|
|
|
|
|
|
Amps |
|
|
|
|
|
| Feet |
|
|
|
|
20 | 12 | 10 | 8 |
25 | 12 | 10 | 6 |
30 | 10 | 8 | 6 |
35 | 10 | 8 | 4 |
40 | 8 | 6 | 2 |
50 | 6 | 4 | 2 |
|
|
|
|
LOADING YOUR GENERATOR SET
With reference to the Receptacle details section, please review the power receptacles fitted to your generator. The circuit breaker rating and the generator rating drive the actual load that may be pulled from each receptacle. The ratings shown in the table are the maximum available from each receptacle.
DO NOT EXCEED THE INDIVIDUAL RECEPTACLE RATINGS
The receptacles shown in this section are for reference only.
Each receptacle is not available on all generators.
ENGINE LIMITATIONS ON GENERATOR
PERFORMANCE
Generator ratings assume 60°F (20C) and Sea Level. Operation of your generator at temperatures above 60°F (20C) or above Sea Level will result in lower electrical output. Electrical output must be derated 1% for each 10°F above 60°F and 3 ½ % for each 1000 feet above mean sea level.
GENERATOR CLEANING
CAUTION: ALWAYS SHUT DOWN THE GENERATOR AND ALLOW IT TO COOL COMPLETELY BEFORE
PERFORMING CLEANING OPERATIONS.
WARNING: DO NOT USE HIGH PRESSURE WATER OR A GARDEN HOSE TO CLEAN YOUR
GENERATOR. WATER INTRODUCED INTO THE GENERATOR CAN CAUSE ELECTRICAL SHORTS, GENERATOR DAMAGE OR PERSONAL INJURY.
•Compressed air (max. 25 psi) may be used to blow loose dirt and dust from your generator. DO NOT DIRECT COMPRESSED AIR DIRECTLY INTO ANY OPENING IN THE GENERATOR OR ENGINE.
•Use a dampened cloth to wipe clean exterior surfaces.
•Use a soft bristle brush to clean/ loosen heavy dirt, oil or grease deposits.
•NEVER insert rags, tools or any device into the generator or engine openings.
English | 11 | 0069439 |
