TROUBLESHOOTING
PROBLEM |
| PROBABLE CAUSE |
| CORRECTIVE ACTION |
|
|
|
| |
Engine Will Not Start | 1. Fuel tank empty. | 1. | Fill fuel tank with fresh fuel/oil mix. | |
|
|
|
| |
Using Recoil Starter | 2. Engine needs choking and priming. | 2. | Move choke control to “CHOKE” position. Push | |
|
|
|
| primer bulb three times. |
| 3. | Spark plug wire disconnected. | 3. | Place spark plug wire onto spark plug. |
|
|
|
|
|
| 4. | Fuel shut off valve closed. | 4. | Move fuel shut off valve to the on position. |
|
|
| ||
Engine Will Not Start | 1. Power extension cord not plugged into machine or | 1. Plug power extension cord into machine & into 120 | ||
Using Electric Starter |
| 120 Volt outlet for U.S.A. or 230 Volt for Europe. |
| Volt outlet for U.S.A. or 230 Volt for Europe. |
| 2. | Power extension cord damaged. | 2. | Discard damaged power extension cord. |
|
|
|
|
|
| 3. | Starter switch damaged or faulty. | 3. | Replace starter switch. |
|
|
|
| |
Engine Stalls or Stops | 1. Water, debris or stale fuel in fuel system. | 1. | Drain and clean fuel system. | |
|
|
|
| |
After Running | 2. Choke control in the “CHOKE” position. | 2. | Move choke control to “OFF” position. | |
|
|
|
|
|
| 3. | Fuel tank empty. | 3. | Fill with fuel to proper level. |
|
|
|
|
|
| 4. | Air intake clogged with snow or debris. | 4. | Unclog air intake. |
|
|
|
|
|
| 5. | Spark plug defective or gap set improperly. | 5. | Service spark plug. |
|
|
|
| |
Engine Loses Power | 1. Engine lubrication oil level is low. | 1. | Add oil to the engine to full level. | |
|
|
|
|
|
| 2. | Spark plug faulty. | 2. | Service spark plug. |
| 3. | Water, debris or stale fuel in fuel system. | 3. | Drain and clean fuel system. |
|
|
|
| |
Excessive Vibration | 1. Damaged, out of balance or bent auger. | 1. | Service auger. | |
|
|
|
|
|
| 2. | Loose engine or auger/impeller components. | 2. | Service and tighten loose components. |
|
|
|
|
|
| 3. | Bent or loose Idler pulley. | 3. | Tighten or replace pulley. |
|
|
|
|
|
| 4. | Cracked, severed or frayed belt. | 4. | Replace belt. |
|
|
| ||
Poor Snow | 1. Clogged discharge chute. | 1. Stop engine and unclog discharge chute. | ||
Discharging | 2. Damaged or bent auger/impeller or components. | 2. Service auger/impeller or components. | ||
| 3. Cracked, severed or frayed belt. | 3. Replace belt. | ||
|
|
| ||
| 4. Belt tension out of adjustment. | 4. Adjust belt tension. | ||
|
|
| ||
| 5. Insufficient lubrication in auger bearings. | 5. Lubricate all bearings as specified in manuals. | ||
|
|
|
|
|
SERVICE SCHEDULE
ITEM | SERVICE PERFORMED | REF. | EACH | 5 | 25 | 50 | 100 | EACH |
|
|
| USE | HRS | HRS | HRS | HRS | SEASON |
Spark Plug | Replace | Engine Manual |
|
|
|
| X |
|
|
|
|
|
|
|
|
|
|
Engine Oil | Check Oil Level | Engine Manual | X |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| Initial Oil Change | Engine Manual |
| X |
|
|
|
|
|
|
|
|
|
|
|
|
|
| Periodic Oil Change | Engine Manual |
|
| X |
|
|
|
|
|
|
|
|
|
|
|
|
Air Filter | Clean or Replace | Engine Manual |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Engine Cooling | Clean Shroud & Fins | Engine Manual |
|
|
|
| X |
|
System |
|
|
|
|
|
|
|
|
Drive Belts | Check For Wear, Tension | Page 11, 13- |
|
| X | X |
| X |
| and Adjustments | 15 |
|
|
|
|
|
|
Auger & | Check For Damage, | Page 11 | X |
|
|
|
| X |
Impeller | Lubrication, Stop Time |
|
|
|
|
|
|
|
Tires | Check Air Pressure | Page 6 | X |
|
|
|
|
|
19
