State Industries GS675YRVLT

These guidelines should be utilized by a qualied service agent.

trouBleshootInG GuIdelInes

Contents

Main Instruction Manual for Your safety Gas Models power vent Gs675YrvIt and Gs675hrvIt wIth hot surface IGnItIon safe InstallatIon, use and servIce Page Page IntroductIon preparInG for the InstallatIon taBle of contents InstallatIon requIreMents for the coMMonwealth of Massachusetts fIGure 1. replaceMent parts and delIMInG products tYpIcal InstallatIon MIXInG valve usaGe facts to consIder aBout the locatIon locatInG the new water heater fIGure 3. fIGure 4. fIGure 5. InsulatIon BlanKets coMBustIon aIr and ventIlatIon for applIances located In unconfIned spaces coMBustIon aIr and ventIlatIon for applIances located In confIned spaces Page InstallInG the new water heater cheMIcal vapor corrosIon water pIpInG teMperature-pressure relIef valve Gas pIpInG sedIMent traps fIllInG the water heater ventInG vent pIpe terMInatIon plannInG the vent sYsteM u.s. horIZontal vent clearances condensate Blower asseMBlY InstallatIon 2. Make sure no material is still attached to the outside or inside of blower assembly. InstallatIon of vent sYsteM vent terMInal InstallatIon, sIdewall Page InstallatIon of vent sYsteM, sIdewall InstallatIon of vertIcal vent sYsteM vent pIpe preparatIon recoMMended Brush* sIZe for prIMer and ceMent applIcatIons Page for Your safetY read Before operatInG warnInG: If you do not follow these instructions exactly, a re or to turn off Gas to applIance operatInG InstructIons teMperature reGulatIon for Your InforMatIon start up condItIons operatIonal condItIons ventInG sYsteM InspectIon Burner operatIon and InspectIon perIodIc MaIntenance Burner cleanInG houseKeepInG anode rod InspectIon teMperature-pressure relIef valve operatIon draInInG leaKaGe checKpoInts servIce repaIr parts lIst natural Gas Burner asseMBlY propane Burner asseMBlY trouBleshootInG GuIdelInes trouBle shootInG water heater control 4. Ensure all ground connections/wires on the water # led status trouBleshootInG GuIdelInes trouBle shootInG Page Page Page condItIons and eXceptIons servIce and laBor responsIBIlItY lIMIted resIdentIal Gas warrantY lIMItatIon on IMplIed warrantIes claIM procedure dIsclaIMers IMportant InforMatIon