Troubleshooting
Problem | Possible Cause | Prevention/Solution |
|
|
|
Burner(s) will not light | • Wire and/or electrode covered with | • Clean wire and/or electrode with rubbing alcohol and clean swab. |
using ignitor. | cooking residue. |
|
| • Electrode and burner are wet. | • Wipe dry with cloth. |
| • Electrode cracked or broken "sparks at | • Replace electrode. |
| crack”. |
|
| • Wire is loose or disconnected. | • Reconnect wire. |
| • Wires are shorting (sparking) between | • Replace ignitor wire/electrode assembly. |
| ignitor and electrode. |
|
| • Bad Ignitor. | • Replace ignitor. |
|
|
|
Burner(s) will not | • No gas flow. | • Check to see if LP tank is empty. If LP tank is not empty, refer to |
match light. |
| "Sudden drop in gas flow". |
| • Coupling nut and regulator not fully | • Turn the coupling nut about |
| connected. | turn until solid stop. Tighten by hand |
| • Obstruction of gas flow. | • Clear burner tube(s). |
| • Disengagement of burner to valve. | • Reengage burner and valve. |
| • Is grill assembled correctly? | • Check steps in assembly instructions. |
|
|
|
Sudden drop in gas | • Out of gas. | • Check for gas in LP tank. |
flow or low flame. | • Excess flow valve tripped. | • Turn off knobs, wait 30 seconds and light grill. If flames are still low, |
|
| turn off knobs and LP tank valve. Disconnect regulator. Reconnect |
|
| regulator and leak test. Turn on LP tank valve, wait 30 seconds and |
|
| then light grill. |
|
|
|
Flames blow out. | • High or gusting winds. | • Turn front of grill to face wind or increase flame height. |
| • Low on LP gas. | • Refill LP tank. |
| • Excess flow valve tripped. | • Refer to "Sudden drop in gas flow" above. |
|
|
|
• Grease buildup. | • Clean grill. | |
| • Excessive fat in meat. | • Trim fat from meat before grilling. |
| • Excessive cooking temperature. | • Adjust (lower) temperature accordingly. |
|
|
|
Persistent grease fire. | • Grease trapped by food buildup around | • Turn knobs to OFF. Turn gas off at LP tank. Leave lid in position and |
| burner system. | let fire burn out. After grill cools, remove and clean all parts. |
|
|
|
Flashback... | • Burner and/or burner tubes are blocked. | • Turn knobs to OFF. Clean burner and/or burner tubes. |
(fire in burner tube(s)). |
|
|
|
|
|
Unable to fill LP tank. | • Some dealers have older fill nozzles | • The worn nozzles don't have enough "bite" to engage the valve. Try |
| with worn threads. | a second LP dealer. |
|
|
|
Certified Grill Parts And Accessories®,
Flame®, Executive Chef®, Faststart®, Flare Fighter®, FlavorMaster®, Gas Grill Silouette and Design®, H2O Smoker®, Lava Flame®, MasterFlame®, MasterFlame Precision Cooking System®, PowerSpark®, Quantum®, VIP®, PrecisionFlame and Design®, Sierra®, and TruFlame® are registered Trademarks of the W.C. Bradley Company. Thermos® is a registered trademark of the Thermos Company and its affiliates.
Artisan Collection by
Protected under one or more of the following U.S. Patents: 4,598,692; 4,624,240; 4,747,391; 4,747,391; 4,817,583; 4,924,846; 4,989,579; 5,003,960; 5,076,256; 5,076,257; 5,090,398; 5,109,834; 5,224,676; 5,277,106; 5,421,319; 5,441,226; 5,452,707; 5,458,309; 5,566,606; 5,566,606; 5,579,755; 5,582,094; 5,613,486; 5,649,475; 5,706,797; 5,711,663; 5,765,543; 5,931,149; 5,996,573; 6,095,132; 6,135,104; 6,173,644; 6,279,566; 6,397,731; 6,418,923; 6,439,222; 6,523,461; D282,619; D339,714; D341,292; D343,337; D358,059; D361,466; D364,535; D372,637; D373,701; D377,735; D383,035; D397,910; D405,643; D405,643; D406,005; D406,009; D413,043; D413,229; D413,229; D414,982; D415,388; D416,164; D416,441; D416,441; D417,587; D422,516; D423,274; D423,876; D428,303; D435,396; D436,004; D438,059; D438,060; D438,427; D439,110; D442,505; D443,179; D443,354; D447,384; D447,385; D447,909; D448,610; D448,614; D448,615; D448,616; D448,975; D449,492; D451,759; D456,202S; D460,313, D461,359 and D477,501. Canada: 87743; 87744; 92607; 92608 and 1,316,424. Other Patents Pending.
461644604 • 11
