PERIODIC MAINTENANCE

Cabinet Cleaning

Victory Refrigeration recommends periodic internal and exterior cleaning as outlined below.

Daily Exterior Cleaning

1.Clean surface with a sponge and cleaning solution. Use a non-abrasive cleaner that does not contain chlorine.

2.Polish with a soft cloth, wiping with the grain of the metal.

3.Once a week wipe with a film cutting agent to maintain shine.

Weekly Interior Cleaning

1.Remove all food, food related items and shelves.

2.Discontinue power to refrigeration system by turning temperature control switch (or dial knob) all the way to the right.

3.Remove loose food particles from interior floors, walls and ceiling.

4.Scrub all interior surfaces with warm detergent solution 100°F - 120°F (38°C - 39°C) and a nylon bristled brush.

5.Rinse with clear water and allow to air dry.

6.Reinstall shelves.

7.Restore power to refrigeration system by turning temperature control switch (or dial knob) to the right.

8.Return food to cabinet when temperature indicator reaches safety zone.

Condenser Maintenance

To keep your cabinet running efficiently, it is recommended that you clean the condenser once every three months. However, once a month is recommended if the unit is located near cooking equipment which produces grease laden vapors, i.e. fryers, grills, steam kettles, etc.

The refrigeration condensing unit is accessible from the front of the Pizza Table Refrigerator. (See Figure 3)

Caution: At installation two shipping screws must be removed from the rear of the condensing unit to allow service from the front of the unit. (Refer to Figure 2)

1.Remove the front refrigeration cover (grill), by removing all screws. Be careful of the Night Switch when removing.

2.Remove power from the Pizza Table Refrigerator by moving the power switch to the “OFF” position.

3.Remove the air baffle located above the condenser.

4.Remove the two screws at the front of the condensing units base.

5.Slide the condensing unit forward to clean.

Caution: The suction line coil will expand to allow the unit to slide forward. Observe the suction line coil as the unit slides forward to ensure no interference is encountered.

6. Reverse the steps for installation and restart of the Pizza Table.

Figure 3

WARNING: Failure to keep condenser clean may cause premature failure of motor-compressor which will NOT be covered by warranty.

Lubrication

Unless otherwise specified, all Victory refrigerators are equipped with oilless type motors. The motor-compressor is a sealed unit and is constantly lubricated when in operation. The condenser and the evaporator motors are equipped with lifetime oiled bearings which never need to be oiled.

3