16.Remove the water reservoir pan. Remove the syphon hose connected to the bottom of the pan. The plastrc pan should then be moved to the left until the right edge can be dropped off the mounting flange. During removal the pan may have to be flexed slightly.
18.Wash the ice maker interior with a mild solution of detergent and rinse with fresh water. Then wipe the ice maker interior with the sanitizer solution (see item 1).
19.Reinstall grids, mercury switch, deflectors and distributors.
NOTE: Mercury switches are to be positioned as indicated on the sketch located on the support rail. Incorrect position
will result in malfunction of the machine.
20 Wash the interior of the bin with a mild solution of detergent, and rinse with fresh water. Then wipe the bin interior with a sanitizing solution made of 100 PPM
household bleach. Directions for obtaining solution strength of 100 PPM are on the bleach container.
21Place the service switch to the “on” position to resume the ice making cycle.
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| If the ice cube maker is to be shut off for several months, | ||||||||||||||
17. Remove |
| each | cutter | grid. |
| Unplug | the | electrical | remove | all | ice | from | the | brn | and | then | Clean | & | Sanitize | the | |||||||||||
connection | and pull | the |
| mercury | switch | out | of | the | ice | maker. |
|
|
|
|
|
|
|
|
|
|
|
| |||||||||
swinging | bracket. | Grids |
| are | held | in | position | on | four | Water | inlet | and | drain | lines | must | be blown | out | if | the | unit | |||||||||||
studs. | “Sliding | clips” | free | the | grid |
| from | the | studs | on | |||||||||||||||||||||
the | left | end | and | then | the | grad slides | off | the | studs | will | be subjected |
| to | freezing | temperatures |
| during | shut | |||||||||||||
nearest | the | freezing |
| plate. |
| The |
| entire |
| grid | can | be | placed | down. | Failure | to | do | so | may | cause the | water | inlet | or drain | ||||||||
into | a “cleaning” | solution |
| (see | item | 1). Allow | the | grid | line | to | freeze | and | rupture. | Disconnect | electricity | to | the | ||||||||||||||
to soak | and | use | a | toothbrush |
| to |
| remove | any | scale | machine | and | leave | the | door | cracked | open | to | prevent | any | |||||||||||
deposit | on | connecting | pins | and | grid | wires. |
|
|
|
| odor | from | develooina. |
|
|
|
|
|
|
|
|
|