Husqvarna BP5 manual Working Condition, Working Plan, Using the Product

BP5

4. For safe operation

WORKING CONDITION

1.Refrain from operating the sprayer if you are tired, ill, or upset, or if you are under the influence of alcohol, drugs or medication.

2.To reduce the risk of injury when filling, using and/or cleaning the sprayer, always wear eye protection. Eye protection should meet the requirements of ANSI Z87.1.

3.Always wear a mask or respirator when filling, using and cleaning sprayer, if recommended by the spray material manufacturer.

4.Wear protective gear and clothing when filling, using and cleaning the sprayer.

5.Wear sturdy rubber-soled shoes or shoes with some other form of anti-slip protection to help protect you against falling when filling, using and/or cleaning the sprayer.

6.Do not wear loose clothing, scarves, neck chains, hair longer than shoulder length, and the like when filling, using and/or cleaning the sprayer.

Check and follow the local regulations.

WORKING PLAN

When planning your work schedule, allow plenty of time to rest. Limit the amount of time over which the product is to be used continuously to somewhere around 30 ~ 40 minutes per session, and take 10 ~ 20 minutes of rest between work sessions. Also try to keep the total amount of work performed in a single day under 2 hours or less.

USING THE PRODUCT

Hose clamps are not completely tight. Please tighten hose clamps prior to using. Hose clamps are left loose to extend life of gaskets and fittings.

Oil cap gasket before using and lubricate weekly so the gasket will seal properly and prevent chemical leaks.

Oil check valve and keep breather

hole clear of debris. Your failure to oil may cause the tank to collapse and crack due to vacuum created by pump lubricate with “3 and 1” oil.

1.Always inspect your sprayer thoroughly before and after each use. Check to be sure hose is securely attached and in good condition before pressurizing the tank.

2.Check the work area that the sprayer will be used in and remove or cover all valuables that may be damaged by using sprayer.

3.To reduce the risk of injury,

•Watch out for children, pets, open windows or freshly washed cars, and spray safely away.

•Do not allow bystanders in work area.

•Do not point the sprayer nozzle in the direction of people or pets.

•Pay attention to the direction of the wind, do not work against the wind.

•Never use the sprayer during windy conditions.

•Never point a sprayer nozzle toward an open flame to avoid the possibility of igniting the unit, causing injury to yourself or damage to surroundings.

•Always release pressure in the pump prior to filling, cleaning, or servicing the sprayer.

•Before opening a container of pesticide or other spray material, carefully read, understand, and follow all instructions on the label.

•Do not use flammable materials in the sprayer: they can ignite and/or explode, causing serious injury.

•Never use caustic or corrosive materials in the sprayer, which could result in damage to the unit.

•In case of personal contamination: remove contaminated clothing, remain upright, do not consume liquids or cause vomiting, and get professional help immediately.

•Never attempt to pressurize the unit by any other method than with the pump module provided. Never over-pressurize the unit.

•Do not eat, drink, or smoke while spraying.

•Wash face and hands with soap and water after spraying.

•Clean and rinse tank and spraying assembly after each use to prevent crystallizing, which would later cause clogging and chemical damage to the unit.

•Do not store sprayer under pressure, or with spray solution in tank.

•Do not transfer spray materials to other containers, especially, food and/or drink containers.

US-4