Poulan PB2042YT, 430097 To Replace Mower Blade Drive Belt See Fig, To Check Brake, Belt Removal

Page 19

SERVICE AND ADJUSTMENTS

TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 28)

The mower blade drive belt may be replaced without tools. Park the tractor on level surface. Engage parking brake.

BELT REMOVAL

•Remove mower from tractor (See “TO REMOVE MOWER” in this section of manual).

•Work belt off both mandrel pulleys and idler pulleys.

•Pull belt away from mower.

BELT INSTALLATION

•Work belt around both mandrel pulleys and idler pul- leys.

•Ensure belt is in all pulley grooves and inside all belt guides.

•Install mower (See "To Install Mower" in this section of manual).

IDLER

PULLEYS

MANDREL

PULLEY

MANDREL

PULLEY

Fig. 28

TO CHECK BRAKE

If tractor requires more than five (5) feet to stop at highest speed in highest gear on a level, dry concrete or paved surface, then brake must be serviced.

You may also check brake by:

•Park tractor on a level, dry concrete or paved surface, depress brake pedal all the way down and engage parking brake.

•Place gear shift lever in neutral (N) position.

The rear wheels must lock and skid when you try to manu- ally push the tractor forward. If the rear wheels rotate, then the brake needs to be serviced. Contact a qualified service center.

TO REPLACE MOTION BELT DRIVE (See Fig. 29)

Park the tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal on bottom side of left footrest.

BELT REMOVAL

•Remove mower (See “TO REMOVE MOWER” in this section of manual).

NOTE: Observe entire motion drive belt and position of all belt guides and keepers.

•Remove belt from stationary idler (A) and clutching idler (B).

•Pull belt slack toward rear of tractor. Carefully remove belt upwards from transmission input pulley and over cooling fan blades (D).

•Remove belt downward from engine pulley (E).

•Slide belt toward rear of tractor, off the steering plate

(F) and remove from tractor.

BELT INSTALLATION

•Install new belt from tractor rear to front, over the steer- ing plate (F) and above clutch brake pedal shaft (G).

•Pull belt toward front of tractor and roll belt onto engine pulley (E).

•Pull belt toward rear of tractor. Carefully work belt down around transmission cooling fan and onto the input pulley (D). Be sure belt is inside the belt keeper.

•Install belt through stationary idler (A) and clutching idler (B).

•Ensure belt is in all pulley grooves and inside all belt guides and keepers.

•Install mower (See “TO INSTALL MOWER” in this section of manual).

E

F

A

G

B

D

02954

Manual

Fig. 29

19

Page 18 Page 20
Image 19
Page 18 Page 20
Contents Model PB2042YTII. Slope Operation Safety RulesSafe Operation Practices for Ride-On Mowers General OperationIV. Towing ServiceGeneral Service III. ChildrenTable of Contents Toremovetractorfromcarton AssemblyTools Required for Assembly Unassembled PartsCheck Brake System Check Tire PressureCheck Deck Levelness Check for Proper Position of ALL BeltsOperation Know Your Tractor To USE Throttle Control D See Fig HOW to USE Your TractorTo SET Parking Brake See Fig Stopping See FigTo Operate on Hills To Operate MowerTo Stop Mower Blades Reverse Operation System ROSADD Gasoline Before Starting the EngineMowing Tips Check Engine OIL LevelSchedule MaintenanceMaintenance General RecommendationsBlade Removal See Fig BatteryTractor Blade CareEngine IN-LINE Fuel Filter See Fig CleaningDeck Washout Port See Fig Slide mower out from under right side of tractor Service and AdjustmentsTo Install Mower See Figs To Remove Mower See FigInstall belt on engine pulley M Turn nut right Turn nut left To raise mower To lower mower To Level MowerTo Replace Motion Belt Drive See Fig Belt InstallationTo Replace Mower Blade Drive Belt See Fig To Check BrakeTo Remove Wheel for Repairs See Fig Transaxle Gear Shift Lever NEUTRAL- Adjustment See FigTo Start Engine with a Weak Battery See Fig Front Wheel TOE-IN/CAMBERTo Replace Headlight Bulb To Adjust Throttle Control CableTo Adjust Choke Control To Adjust CarburetorEngine OIL StorageOther Fuel SystemProblem Cause Correction Troubleshooting PointsExcessive To run when operBattery will not When turningService Notes Service Notes Suggested Guide for Sighting Slopes for Safe Operation Stevens Creek Road Terry Fox Way Augusta, GA 30907 USA Outdoor Products Customer Service DeptHOP Canada contactGarantie cette de exclus sont normal l’entretien et Dept Service Customer Products OutdoorCanada Au AutoriséDegrés Dentretien Remarques Correction Cause Problème Dépannage DE GuidePuissance de Dentretien Remarques Entreposage Carburateur LE Régler Pour Starter DU Commande LA Régler PourGAZ DES Commande LA DE Câble LE Régler Pour Réglages ET RévisionFig la Voir Faible Rietebat RossageAVANT/CAR Roues DES Convergence 30 .Fig’EN Courroie LA Remplacer Pour Fig la Voir D’ENTRAÎNEMENT Courroie a L Acer Rempl PourFig la Voir Tondeuse DE Lame DE Mentnetraî25 .Fig Tondeuse LA Niveau LE Ajuster Pour27 .Fig 26 .Fig20 .Fig 23 .Fig22 .Fig 21 .FigGaged Fig VoirTondeuse LA Enlever Pour 18 .Fig61 .Fig EntretienFig La Voir Coupe DE Plateau DU Lavage DE Raccord 17 .FigLubrification ’ALLUMAGE Bougie’AIR Tamis LE Nettoyer AIR À FiltreFrein DU Fonctionnement Fig la Voir Lame LA EnleverLames DES Entretien PneusUtilisation Chaque Avant EntretienLubrification DE Tableau Moteur DU D’HUILE Niveau LE Vérifier UtilisationTonte DE Conseils ’ESSENCE Réservoir LE RemplirTracteur LE Transporter Pour Accessoires AutresFiglaVoirTONDEUSELAUTILISERPOUR ET Charrettes DES Remorquer PourFig la Voir Mentnetionsta DE Frein LE Engager Pour GAZ DES Commande LA Utiliser PourReculer Pour ET Avancer Pour Fig la Voir Arrêter Pour 6 .FigPrésence DE Système DU Commutateur G Propriété la de lendommagement Desmancom des fonction la et MontageTionsec la Voir Rouler Faisant LE EN TE Fig la Voir Batterie LA Vérifier Montar SIN PiezasDE Tracteur LE Retirer Avant Fig la Voir Siège LE AjustezSommaire ’ESSENCE DE Sûre Manipulation Général EntretienTracteurs des sécurité toute ’utilisation pour ConseilsLES Dans Fonctionnement PentesTracteurs des sécurité toute en l’utilisation pour Conseils Avertissement Rev

PB2042YT, 430097, 96042011200 specifications

The Poulan 96042011200,430097,PB2042YT is a highly regarded lawn tractor that offers users a blend of performance, comfort, and advanced technology, making yard maintenance easy and efficient. This model is especially designed for homeowners with medium to large-sized lawns, featuring a robust engine and a variety of functionalities to enhance the mowing experience.

One of the standout features of the PB2042YT is its powerful engine. It is equipped with a dependable gas engine that provides ample torque and speed for mowing through thick grass and uneven terrain. The tractor’s 42-inch cutting deck is wide enough to cover a significant amount of ground in a single pass, which drastically reduces mowing time. The adjustable cutting height allows users to customize the blade height from one to four inches, accommodating different grass types and preferences.

Another notable aspect of the Poulan PB2042YT is its user-friendly design. The tractor features a comfortable, adjustable seat with armrests, ensuring that users can mow their lawns without discomfort, even during extended sessions. Additionally, the control panel is intuitively designed, allowing users to easily access the ignition, throttle, and PTO (Power Take-Off) switches.

The Poulan PB2042YT also integrates advanced technology that enhances its functionality. The automatic transmission provides smooth acceleration and effortless gear changes, so users can concentrate on steering and cutting without worrying about shifting gears. Furthermore, the tight turning radius of this model makes it easy to maneuver around flower beds, trees, and garden ornaments with precision.

Safety features are also a priority in the PB2042YT. The lawn tractor comes equipped with an automatic blade shut-off system that activates when the operator leaves the seat, minimizing the risk of accidents.

In summary, the Poulan 96042011200,430097,PB2042YT is a comprehensive lawn maintenance solution that combines power, comfort, and safety features. Its versatile cutting options, user-friendly controls, and reliable engine make it an excellent choice for homeowners looking to achieve a well-maintained lawn without the hassle. Whether tackling vast lawns or intricate landscapes, this lawn tractor is designed to deliver exceptional performance and results.
Top Page Image Contents