Poulan PB2042YT, 430097, 96042011200 manual Storage, Other, Fuel System, Engine OIL, Cylinders

Page 22

STORAGE

Immediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more.

WARNING: Never store the tractor with gasoline in the tank inside a building where fumes may reach an open flame or spark. Allow the engine to cool before storing in any enclosure.

TRACTOR

Remove mower from tractor for winter storage. When mower is to be stored for a period of time, clean it thoroughly, remove all dirt, grease, leaves, etc. Store in a clean, dry area.

•Clean entire tractor (See “CLEANING” in the Mainte- nance section of this manual).

•Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual).

•Lubricate as shown in the Maintenance section of this manual.

•Be sure that all nuts, bolts and screws are securely fastened. Inspect moving parts for damage, breakage and wear. Replace if necessary.

•Touch up all rusted or chipped paint surfaces; sand lightly before painting.

BATTERY

•Fully charge the battery for storage.

•After a period of time in storage, battery may require recharging.

•To help prevent corrosion and power leakage during long periods of storage, battery cables should be dis- connected and battery cleaned thoroughly (see “TO CLEAN BATTERY AND TERMINALS” in the Mainte- nance section of this manual).

•After cleaning, leave cables disconnected and place cables where they cannot come in contact with battery terminals.

•If battery is removed from tractor for storage, do not store battery directly on concrete or damp surfaces.

ENGINE

FUEL SYSTEM

IMPORTANT: IT IS IMPORTANT TO PREVENT GUM DEPOSITS FROM FORMING IN ESSENTIAL FUEL SYSTEM PARTS SUCH AS CARBURETOR, FUEL FILTER, FUEL HOSE, OR TANK DURING STORAGE. ALSO, EXPERIENCE INDICATES THAT ALCOHOL BLENDED FUELS (CALLED GASOHOL OR USING ETHANOL OR METHANOL) CAN ATTRACT MOISTURE WHICH LEADS TO SEPARATION AND FORMATION OF ACIDS DURING STORAGE. ACIDIC GAS CAN DAMAGE THE FUEL SYSTEM OF AN ENGINE WHILE IN STORAGE.

•Empty the fuel tank by starting the engine and let it run until the fuel lines and carburetor are empty.

•Never use engine or carburetor cleaner products in the fuel tank or permanent damage may occur.

•Use fresh fuel next season.

NOTE: Fuel stabilizer is an acceptable alternative in mini- mizing the formation of fuel gum deposits during storage. Add stabilizer to gasoline in fuel tank or storage container. Always follow the mix ratio found on stabilizer container. Run engine at least 10 minutes after adding stabilizer to allow the stabilizer to reach the carburetor. Do not empty the gas tank and carburetor if using fuel stabilizer.

ENGINE OIL

Drain oil (with engine warm) and replace with clean en- gine oil. (See “ENGINE” in the Maintenance section of this manual).

CYLINDER(S)

•Remove spark plug(s).

•Pour one ounce of oil through spark plug hole(s) into cylinder(s).

•Turn ignition key to “START” position for a few seconds to distribute oil.

•Replace with new spark plug(s).

OTHER

•Do not store gasoline from one season to another.

•Replace your gasoline can if your can starts to rust. Rust and/or dirt in your gasoline will cause problems.

•If possible, store your tractor indoors and cover it to give protection from dust and dirt.

•Cover your tractor with a suitable protective cover that does not retain moisture. Do not use plastic. Plastic cannot breathe which allows condensation to form and will cause your tractor to rust.

IMPORTANT: NEVER COVER TRACTOR WHILE ENGINE AND EXHAUST AREAS ARE STILL WARM.

22

Page 21 Page 23
Image 22
Page 21 Page 23
Contents PB2042YT ModelGeneral Operation Safety RulesSafe Operation Practices for Ride-On Mowers II. Slope OperationIII. Children ServiceGeneral Service IV. TowingTable of Contents Unassembled Parts AssemblyTools Required for Assembly ToremovetractorfromcartonCheck for Proper Position of ALL Belts Check Tire PressureCheck Deck Levelness Check Brake SystemOperation Know Your Tractor Stopping See Fig HOW to USE Your TractorTo SET Parking Brake See Fig To USE Throttle Control D See FigReverse Operation System ROS To Operate MowerTo Stop Mower Blades To Operate on HillsCheck Engine OIL Level Before Starting the EngineMowing Tips ADD GasolineGeneral Recommendations MaintenanceMaintenance ScheduleBlade Care BatteryTractor Blade Removal See FigEngine IN-LINE Fuel Filter See Fig CleaningDeck Washout Port See Fig To Remove Mower See Fig Service and AdjustmentsTo Install Mower See Figs Slide mower out from under right side of tractorInstall belt on engine pulley M To Level Mower Turn nut right Turn nut left To raise mower To lower mowerTo Check Brake Belt InstallationTo Replace Mower Blade Drive Belt See Fig To Replace Motion Belt Drive See FigFront Wheel TOE-IN/CAMBER Transaxle Gear Shift Lever NEUTRAL- Adjustment See FigTo Start Engine with a Weak Battery See Fig To Remove Wheel for Repairs See FigTo Adjust Carburetor To Adjust Throttle Control CableTo Adjust Choke Control To Replace Headlight BulbFuel System StorageOther Engine OILTroubleshooting Points Problem Cause CorrectionWhen turning To run when operBattery will not ExcessiveService Notes Service Notes Suggested Guide for Sighting Slopes for Safe Operation Canada contact Outdoor Products Customer Service DeptHOP Stevens Creek Road Terry Fox Way Augusta, GA 30907 USAAutorisé Dept Service Customer Products OutdoorCanada Au Garantie cette de exclus sont normal l’entretien etDegrés Dentretien Remarques Dépannage DE Guide Correction Cause ProblèmePuissance de Dentretien Remarques Entreposage Réglages ET Révision Starter DU Commande LA Régler PourGAZ DES Commande LA DE Câble LE Régler Pour Carburateur LE Régler Pour30 .Fig RossageAVANT/CAR Roues DES Convergence Fig la Voir Faible RietebatTondeuse DE Lame DE Mentnetraî Fig la Voir D’ENTRAÎNEMENT Courroie a L Acer Rempl PourFig la Voir ’EN Courroie LA Remplacer Pour26 .Fig Tondeuse LA Niveau LE Ajuster Pour27 .Fig 25 .Fig21 .Fig 23 .Fig22 .Fig 20 .Fig18 .Fig Fig VoirTondeuse LA Enlever Pour Gaged17 .Fig EntretienFig La Voir Coupe DE Plateau DU Lavage DE Raccord 61 .FigAIR À Filtre ’ALLUMAGE Bougie’AIR Tamis LE Nettoyer LubrificationPneus Fig la Voir Lame LA EnleverLames DES Entretien Frein DU FonctionnementUtilisation Chaque Avant EntretienLubrification DE Tableau ’ESSENCE Réservoir LE Remplir UtilisationTonte DE Conseils Moteur DU D’HUILE Niveau LE VérifierET Charrettes DES Remorquer Pour Accessoires AutresFiglaVoirTONDEUSELAUTILISERPOUR Tracteur LE Transporter PourFig la Voir Arrêter Pour 6 .Fig GAZ DES Commande LA Utiliser PourReculer Pour ET Avancer Pour Fig la Voir Mentnetionsta DE Frein LE Engager PourPrésence DE Système DU Commutateur G Propriété la de lendommagement Desmancom des fonction la et MontageTionsec la Voir Rouler Faisant LE EN TE Fig la Voir Siège LE Ajustez Montar SIN PiezasDE Tracteur LE Retirer Avant Fig la Voir Batterie LA VérifierSommaire ’utilisation pour Conseils Général EntretienTracteurs des sécurité toute ’ESSENCE DE Sûre ManipulationLES Dans Fonctionnement PentesTracteurs des sécurité toute en l’utilisation pour Conseils Rev Avertissement

PB2042YT, 430097, 96042011200 specifications

The Poulan 96042011200,430097,PB2042YT is a highly regarded lawn tractor that offers users a blend of performance, comfort, and advanced technology, making yard maintenance easy and efficient. This model is especially designed for homeowners with medium to large-sized lawns, featuring a robust engine and a variety of functionalities to enhance the mowing experience.

One of the standout features of the PB2042YT is its powerful engine. It is equipped with a dependable gas engine that provides ample torque and speed for mowing through thick grass and uneven terrain. The tractor’s 42-inch cutting deck is wide enough to cover a significant amount of ground in a single pass, which drastically reduces mowing time. The adjustable cutting height allows users to customize the blade height from one to four inches, accommodating different grass types and preferences.

Another notable aspect of the Poulan PB2042YT is its user-friendly design. The tractor features a comfortable, adjustable seat with armrests, ensuring that users can mow their lawns without discomfort, even during extended sessions. Additionally, the control panel is intuitively designed, allowing users to easily access the ignition, throttle, and PTO (Power Take-Off) switches.

The Poulan PB2042YT also integrates advanced technology that enhances its functionality. The automatic transmission provides smooth acceleration and effortless gear changes, so users can concentrate on steering and cutting without worrying about shifting gears. Furthermore, the tight turning radius of this model makes it easy to maneuver around flower beds, trees, and garden ornaments with precision.

Safety features are also a priority in the PB2042YT. The lawn tractor comes equipped with an automatic blade shut-off system that activates when the operator leaves the seat, minimizing the risk of accidents.

In summary, the Poulan 96042011200,430097,PB2042YT is a comprehensive lawn maintenance solution that combines power, comfort, and safety features. Its versatile cutting options, user-friendly controls, and reliable engine make it an excellent choice for homeowners looking to achieve a well-maintained lawn without the hassle. Whether tackling vast lawns or intricate landscapes, this lawn tractor is designed to deliver exceptional performance and results.
Top Page Image Contents