Poulan PO14542LT, 438511, 96012011200 manual Excessive

Page 25

TROUBLESHOOTING POINTS

PROBLEM

CAUSE

CORRECTION

Excessive

1.

Worn, bent or loose blade.

1.

Replace blade. Tighten blade bolt.

vibration

2.

Bent blade mandrel.

2.

Replace blade mandrel.

 

3.

Loose/damaged part(s).

3.

Tighten loose part(s). Replace damaged parts.

 

 

 

 

 

 

Engine continues

1.

Faulty operator-safety presence control

1.

Check wiring, switches and connections. If not

 

to run when oper-

 

system.

 

corrected, contact an authorized service center/

 

 

 

department.

ator leaves seat

 

 

 

 

 

 

 

 

with attachment

 

 

 

 

 

clutch engaged

 

 

 

 

 

 

 

 

 

 

 

Poor cut - uneven

1.

Worn, bent or loose blade.

1.

Replace blade. Tighten blade bolt.

 

 

2.

Mower deck not level.

2.

Level mower deck.

 

3.

Buildupofgrass,leaves,ortrashundermower.

3.

Clean underside of mower housing.

 

4.

Bent blade mandrel.

4.

Replace blade mandrel.

 

5.

Clogged mower deck vent holes from buildup

5.

Clean around mandrels to open vent holes.

 

 

of grass, leaves, and trash around mandrels.

 

 

 

Mower blades will

1.

Obstruction in clutch mechanism.

1.

Remove obstruction.

 

not rotate

2.

Worn/damaged mower drive belt.

2.

Replace mower drive belt.

 

3.

Frozen idler pulley.

3.

Replace idler pulley.

 

4.

Frozen blade mandrel.

4.

Replace blade mandrel.

 

 

 

 

 

 

Poor grass

1.

Engine speed too slow.

1.

Place throttle control in “FAST” position.

 

discharge

2.

Travel speed too fast.

2.

Shift to slower speed.

 

3.

Wet grass.

3.

Allow grass to dry before mowing.

 

4.

Mower deck not level.

4.

Level mower deck.

 

5.

Low/uneven tire air pressure.

5.

Check tires for proper air pressure.

 

6.

Worn, bent or loose blade.

6.

Replace blade. Tighten blade bolt.

 

7.

Buildup of grass, leaves and trash under

7.

Clean underside of mower housing.

 

 

mower.

 

 

 

 

8.

Mower drive belt worn.

8.

Replace mower drive belt.

 

9.

Blades improperly installed.

9.

Reinstall blades sharp edge down.

 

10.

Improper blades used.

10.

Replace with blades listed in parts manual.

 

11.

Clogged mower deck vent holes from buildup

11.

Clean around mandrels to open vent holes.

 

 

of grass, leaves, and trash around mandrels.

 

 

 

Headlight(s) not

1.

Switch is “OFF”.

1.

Turn switch “ON”.

 

working

2.

Bulb(s) or lamp(s) burned out.

2.

Replace bulb(s) or lamp(s).

(if so equipped)

3.

Faulty light switch.

3.

Check/replace light switch.

 

4.

Loose or damaged wiring.

4.

Check wiring and connections.

 

5.

Blown fuse.

5.

Replace fuse.

 

 

 

 

 

 

Battery will not

1.

Bad battery cell(s).

1.

Replace battery.

 

charge

2.

Poor cable connections.

2.

Check/clean all connections.

 

3.

Faulty regulator (if so equipped).

3.

Replace regulator.

 

4.

Faulty alternator.

4.

Replace alternator.

 

 

 

 

 

 

Loss of drive

1.

Debris on steering plate (if equipped).

1.

See "CLEANING" in the maintenance section.

 

 

2.

Motion drive belt worn, damaged, or broken.

2.

Replace motion drive belt.

 

3.

Axle key missing.

3.

Install axle key at rear wheel. See "TO REMOVE

 

 

 

 

WHEEL" in the Service and Adjustments section.

Engine“backfires”

1.

Engine throttle control not set between

1.

Move throttle control between half and full speed

 

when turning

 

half and full speed (fast) position before

 

(fast) position before stopping engine.

 

stopping engine.

 

 

 

engine “OFF”

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Engine dies when

1.

Reverse operation system (ROS) is not

1.

Turn ignition key to ROS "ON" position. See

 

tractor is shifted

 

"ON" while mower or other attachment is

 

Operation section.

into reverse

 

engaged.

 

 

 

 

 

 

 

 

 

 

 

 

 

 

25

Page 24 Page 26
Image 25
Page 24 Page 26
Contents PO14542LT Safe Operation Practices for Ride-On Mowers Safety RulesGeneral Operation II. Slope OperationIII. Children ServiceIV. Towing Table of Contents Steering Wheel Unassembled PartsTools Required for Assembly AssemblyTo Remove Tractor from Carton Before Removing Tractor from SkidCheck for Proper Position of ALL Belts Check Deck LevelnessCheck Brake System Check Tire PressureOperation Know Your Tractor HOW to USE Your Tractor To Operate on Hills Reverse Operation System ROSTo Transport Towing Carts and Other AttachmentsCheck Engine OIL Level Before Starting the EngineADD Gasoline To Start Engine See FigMowing Tips General Recommendations MaintenanceTractor BatteryBlade Care Blade Removal See FigEngine Transaxle MaintenanceBelts LubricationClean AIR Screen CleaningAIR Filter MufflerTo Install Mower See Fig Service and AdjustmentsTo Remove Mower See Fig FRONT-TO-BACK Adjustment See Figs To Level Mower HousingTo Check Brake To Replace Mower Blade Drive Belt See FigTo Replace Motion Drive Belt See Fig To Adjust Steering Wheel Alignment Transaxle Gear Shift Lever Neutral Adjustment See FigTo Start Engine with a Weak Battery See Fig Front Wheel TOE-IN/CAMBERTo Adjust Choke Control To Adjust Throttle Control CableTo Adjust Carburetor To Replace Headlight BulbOther StorageFuel System Engine OILTroubleshooting Points Excessive Service Notes Only Ride UP and Down Hill Not Across Hill Degrees MAX Suggested Guide for Sighting Slopes for Safe OperationLimited Warranty
Related manuals
Manual 20 pages 52.33 Kb

96012011200, PO14542LT, 438511 specifications

The Poulan PO14542LT is a powerful and versatile lawn tractor designed to make yard care easier for homeowners. With its robust features and advanced technologies, this ride-on mower stands out as an excellent choice for those managing medium to large-sized lawns.

One of the main features of the Poulan PO14542LT is its 14.5 horsepower Briggs & Stratton engine. The engine provides reliable power to tackle tough mowing tasks, ensuring efficient cutting and handling of overgrown grass. Coupled with an automatic transmission, the tractor allows for smooth speed adjustments without the need for manual gear shifting, enhancing user convenience and comfort.

The cutting deck is another standout characteristic of the PO14542LT. With a 42-inch width, the deck is designed to deliver a clean and even cut, helping to reduce the number of passes required on your lawn. It also features a 3-in-1 cutting system that allows users to choose between mulching, bagging, or side discharge options, providing flexibility based on the specific needs of the lawn.

In terms of ergonomics, the Poulan PO14542LT is designed with the user in mind. The high-back seat provides comfort during long mowing sessions, while the easy-to-reach controls allow for effortless operation. The steering wheel is designed for ease of maneuverability, making it simple to navigate around obstacles in the yard.

Safety is a priority in the design of this tractor. The PO14542LT comes equipped with a safety switch that ensures the engine will shut off if the operator leaves the seat while the mower is engaged. Additionally, the tractor includes oversized batteries and an efficient fuel economy, allowing for extended operation between refuels.

Poulan also incorporates advanced technologies into the PO14542LT. The dual-blade cutting system enhances grass chopping capabilities, promoting healthier lawn growth by finely cutting the grass clippings that are returned to the soil. This, combined with the mulching capability, supports environmentally friendly yard maintenance.

In conclusion, the Poulan PO14542LT is an impressive lawn tractor that excels in performance, comfort, and versatility. Its combination of power, user-friendly features, and safety mechanisms makes it an ideal companion for homeowners seeking to achieve a beautifully maintained lawn with minimal effort. Whether it’s routine mowing or tackling tougher terrains, the PO14542LT proves to be a reliable choice for any lawn care endeavor.
Top Page Image Contents