Poulan 96012011100, 438495 manual To Replace Headlight Bulb, Interlocks and Relays, To Replace Fuse

Page 23

SERVICE AND ADJUSTMENTS

REPLACING BATTERY (See Fig. 23)

WARNING: Do not short battery terminals by allowing a wrench or any other object to contact both terminals at the same time. Before connecting battery, remove metal bracelets, wristwatch bands, rings, etc. Positive terminal must be connected first to prevent sparking from accidental grounding.

•Lift seat pan to raised position.

•Disconnect BLACK battery cable first then RED battery cable and carefully remove battery from tractor.

•Install new battery with terminals in same position as old battery.

•First connect RED battery cable to positive (+) terminal with bolt and nut as shown. Tighten securely. Slide terminal cover over terminal.

•Connect BLACK grounding cable to negative (-) ter- minal with remaining bolt and nut. Tighten securely.

•Lower seat pan.

SEAT PAN

02602

TERMINAL

 

NUT

COVER

 

 

BOLT

 

 

POSITIVE

 

NEGATIVE

(RED)

 

 

(BLACK)

CABLE

 

 

CABLE

 

02603

Fig. 23

TO REPLACE HEADLIGHT BULB

•Raise hood.

•Pull bulb holder out of the hole in the backside of the grill.

•Replace bulb in holder and push bulb holder securely back into the hole in the backside of the grill.

•Close hood.

INTERLOCKS AND RELAYS

Loose or damaged wiring may cause your tractor to run poorly, stop running, or prevent it from starting.

•Check wiring. See electrical wiring diagram in the Repair Parts section.

TO REPLACE FUSE

Replace with 20 amp automotive-type plug-in fuse. The fuse holder is located behind the dash.

TO REMOVE HOOD AND GRILL ASSEMBLY (See Fig. 24)

•Raise hood.

•Unsnap headlight wire connector.

•Stand in front of tractor. Grasp hood at sides, tilt toward engine and lift off of tractor.

•To replace, reverse above procedure.

HOOD

HEADLIGHT

WIRE

CONNECTOR

02495

Fig. 24

ENGINE

TO ADJUST THROTTLE CONTROL CABLE

The throttle control has been preset at the factory and adjustment should not be necessary. If adjustment is nec- essary, see engine manual.

TO ADJUST CHOKE CONTROL

The choke control has been preset at the factory and ad- justment should not be necessary. If adjustment is neces- sary, see engne manual.

TO ADJUST CARBURETOR

Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment.

23

Page 22 Page 24
Image 23
Page 22 Page 24
Contents Model PO19542LTII. Slope Operation Safety RulesSafe Operation Practices for Ride-On Mowers General OperationIV. Towing ServiceGeneral Service III. ChildrenTable of Contents Steering Wheel Unassembled PartsBefore Removing Tractor from Skid AssemblyTools Required for Assembly ToremovetractorfromcartonCheck for Proper Position of ALL Belts To Check Battery See FigCheck Tire Pressure Check Deck LevelnessChecklist Operation Know Your Tractor HOW to USE Your Tractor Towing Carts and Other ATTACH- Ments Reverse Operation System ROSTo Operate on Hills To TransportTo Start Engine See Fig Before Starting the EngineCheck Engine OIL Level ADD GasolineMowing Tips Schedule MaintenanceMaintenance General RecommendationsBlade Removal See Fig BatteryTractor Blade CareEngine IN-LINE Fuel Filter See Fig CleaningTo Remove Mower See Fig Service and AdjustmentsTo Install Mower See Fig FRONT-TO-BACK Adjustment See Figs To Level Mower HousingTo Replace Motion Drive Belt See Fig To Replace Mower Blade Drive Belt See FigTo Check Brake Front Wheel TOE-IN/CAMBER Transaxle Gear Shift Lever NEUTRAL- Adjustment See FigTo Adjust Steering Wheel ALIGN- Ment To Start Engine with a Weak Battery See FigTo Replace Headlight Bulb To Adjust Throttle Control CableTo Adjust Choke Control To Adjust CarburetorEngine OIL StorageOther Fuel SystemProblem Cause Correction Troubleshooting PointsExcessive Limited Warranty Service Notes Only Ride UP and Down Hill Not Across Hill Degrees MAX Suggested Guide for Sighting Slopes for Safe OperationParts and Service
Related manuals
Manual 20 pages 23.31 Kb

96012011100, PO19542LT, 438495 specifications

The Poulan PO19542LT, model number 96012011100, is a robust and reliable lawn tractor designed to meet the diverse needs of homeowners and landscaping enthusiasts alike. This powerful machine stands out in the crowded market of lawn care equipment, thanks to its advanced features, durable construction, and user-friendly operation.

At the heart of the Poulan PO19542LT is a reliable, efficient engine that provides the necessary power to tackle tough mowing tasks. The engine is designed to deliver consistent performance while ensuring optimal fuel efficiency. With a cutting width of 42 inches, this lawn tractor enables users to cover large areas in fewer passes, significantly reducing the time spent mowing lawns.

One of the key features of the Poulan PO19542LT is its hydrostatic transmission, which provides seamless speed adjustment and enhances maneuverability. This technology allows users to easily navigate around obstacles, making it an ideal choice for yards with intricate landscaping. Additionally, the responsive steering and tight turning radius further enhance handling and control, offering a more enjoyable mowing experience.

The cutting deck of the PO19542LT is another highlight, featuring a durable steel construction that can withstand the rigors of regular use. The deck also comes equipped with multiple cutting heights, allowing users to choose the desired grass length for a clean, well-manicured lawn. Furthermore, the deck's design promotes effective grass discharge, whether through side discharge, mulching, or bagging, catering to various lawn care preferences.

Comfort is paramount in lawn maintenance, and Poulan addresses this with an ergonomic seat and easy-to-reach controls. The high-back seat offers ample support for long mowing sessions, while the spacious foot area allows users to work comfortably without feeling cramped.

Safety features are integral to the design of the Poulan PO19542LT, ensuring that users can operate the tractor without unnecessary risk. The presence of safety switches and guards ensures that the machine operates only when the operator is securely seated, further enhancing safety during operation.

In conclusion, the Poulan PO19542LT, 96012011100, 438495 is a versatile lawn tractor that combines power, efficiency, and user comfort. With its advanced hydrostatic transmission, sturdy construction, and multiple cutting options, this model is designed to make lawn care tasks easier and more efficient. Whether you're maintaining a small residential yard or larger lawns, the Poulan PO19542LT is well-equipped to deliver outstanding performance and results.
Top Page Image Contents