Poulan 96042012500, 532 43 85-70 manual Transmission

Page 23

SERVICE AND ADJUSTMENTS

REPLACING BATTERY (See Fig. 35)

WARNING: Do not short battery termi- nals by allowing a wrench or any other object to contact both terminals at the same time. Before connecting battery, remove metal bracelets, wristwatch bands, rings, etc. Positive terminal must be connected first to prevent sparking from accidental grounding.

•Lift hood to raised position.

•Remove terminal cover.

•Disconnect BLACK battery cable then RED battery cable and carefully remove battery from tractor.

•Install new battery with terminals in same position as old battery.

•Reinstall terminal cover.

•First connect RED battery cable to positive (+) battery terminal with bolt and nut as shown. Tighten securely.

•Connect BLACK grounding cable to negative (-) battery terminal with remaining bolt and nut. Tighten securely

•Close hood.

NEGATIVE (BLACK)

CABLE

TERMINAL

COVER

POSITIVE (RED)

CABLE

Fig. 35

TO REPLACE HEADLIGHT BULB

•Raise hood.

•Pull bulb holder out of the hole in the backside of the grill.

•Replace bulb in holder and push bulb holder securely back into the hole in the backside of the grill.

•Close hood.

INTERLOCKS AND RELAYS

Loose or damaged wiring may cause your tractor to run poorly, stop running, or prevent it from starting.

•Check wiring.

TO REPLACE FUSE

Replace with 20 amp automotive-type plug-in fuse. The fuse holder is located behind the dash.

TO REMOVE HOOD AND GRILL ASSEMBLY (See Fig. 36)

•Raise hood.

•Unsnap headlight wire connector.

•Stand in front of tractor. Grasp hood at sides, tilt toward engine and lift off of tractor.

•To replace, reverse above procedure.

HOOD

HEADLIGHT

WIRE

CONNECTOR

02778

Fig. 36

TRANSMISSION

REMOVAL/REPLACEMENT

Should your transmission require removal for service or replacement, it should be purged after reinstallation and beforeoperating thetractor. See “PURGE TRANSMISSION” in the Operation section of this manual.

ENGINE

TO ADJUST THROTTLE CONTROL CABLE

The throttle control has been preset at the factory and adjustment should not be necessary. If adjustment is nec- essary, see engine manual.

TO ADJUST CARBURETOR

Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment.

23

Page 22 Page 24
Image 23
Page 22 Page 24
Contents PB22H46YT II. Slope Operation Safety RulesSafe Operation Practices for Ride-On Mowers General OperationIV. Towing ServiceIII. Children Table of Contents Toremovetractorfromcarton AssemblyTools Required for Assembly Unassembled PartsCheck Brake System Check Tire PressureCheck Deck Levelness Check for Proper Position of ALL BeltsOperation PH EG CJK Know Your TractorTo USE Throttle Control D See Fig HOW to USE Your TractorTo SET Parking Brake See Fig Stopping See FigTo USE Cruise Control J See Fig To Adjust Mower Cutting Height See FigTo Adjust Gauge Wheels See Fig To Move Forward and Backward See FigTo Operate on Hills Using the Reverse Operation SystemTo Stop Mower Blades Reverse Operation System ROS See FigADD Gasoline Service REMINDER/HOUR MeterBefore Starting the Engine Check Engine OIL LevelPurge Transmission Mowing TipsSchedule MaintenanceMaintenance General RecommendationsBlade Removal See Fig BatteryTractor Blade CareEngine Deck Washout Port See Fig CleaningIN-LINE Fuel Filter See Fig To Remove Mower See Fig To Install Mower See FigInstall belt on engine pulley M, in belt keepers G To Level Mower To Replace Motion Drive Belt See Fig Belt InstallationTo Replace Mower Blade Drive Belt See Fig To Check BrakeTo Remove Wheel See Fig Service and AdjustmentsTo Start Engine with a Weak Battery See Fig Front Wheel TOE-IN/CAMBERTransmission Engine OIL StorageOther Fuel SystemTroubleshooting Engine continues Only Ride UP and Down Hill Not Across Hill Degrees MAX Suggested Guide for Sighting Slopes for Safe OperationLimited Warranty

96042012500, 532 43 85-70 specifications

The Poulan 532 43 85-70,96042012500 is a powerful and reliable equipment designed for garden maintenance and landscaping tasks. Known for its robust construction and efficient performance, this model caters to both professional landscapers and home gardeners looking for efficiency and ease of use.

One of the key features of the Poulan 532 43 85-70,96042012500 is its powerful engine. Packed with a high-performance motor, it delivers ample power for various tasks, including mowing, trimming, and edging. The engine is designed for fuel efficiency, allowing users to complete their gardening tasks with minimal downtime for refueling. This efficiency makes it an ideal choice for those who have large lawns or gardens that require regular maintenance.

The cutting system is another remarkable aspect of this model. Equipped with a sharp, durable blade, the Poulan ensures a clean and precise cut on grass and vegetation. The adjustable cutting height feature is particularly beneficial for users who desire versatility, allowing them to easily change the blade height to accommodate different types of grass and terrain.

User comfort is also a priority in the design of the Poulan 532 43 85-70,96042012500. The ergonomic grip and lightweight structure enable easy maneuverability, ensuring that operators do not experience fatigue even during extended use. The user-friendly controls ensure that even beginners can operate the equipment without difficulty.

The durability of the Poulan is enhanced by its weather-resistant materials, making it a desirable option for varying climates. Its sturdy frame ensures long-lasting performance, allowing users to rely on this tool for years without needing frequent repairs or replacements.

Additionally, the Poulan 532 43 85-70,96042012500 is designed with safety features to protect users during operation. The blade guard and automatic shut-off mechanisms help prevent accidents, making it a safe option for families and workplaces alike.

Overall, the Poulan 532 43 85-70,96042012500 stands out for its combination of power, efficiency, and user-friendly design. It is an excellent investment for anyone looking to achieve professional-quality results in their lawn maintenance and landscaping endeavors.
Top Page Image Contents