Poulan 435712, 96042007202 Table Of Contents, Product Specifications, Customer Responsibilities

Page 4
PRODUCT SPECIFICATIONS

PRODUCT SPECIFICATIONS

Gasoline Capacity

1.50 Gallons

 

and Type:

Unleaded Regular

Oil Type (API-SG-SL):

SAE 30 (above 32°F)

 

SAE 5W-30 (below 32°F)

Oil Capacity:

48 oz.

 

 

 

Spark Plug:

Champion RC12YC

 

(Gap: .030")

 

Ground Speed (MPH):

Forward:

0 - 5.2

 

Reverse:

0 - 2.9

Charging System:

3 Amps Battery

 

5 Amps Headlights

Battery:

AMP/HR:

28

 

Min. CCA:

230

 

Case Size:

U1R

Blade Torque:

45-55 FT. LBS.

CONGRATULATIONS on your purchase of a new tractor. It has been designed, engineered and manufactured to give you the best possible dependability and performance.

Should you experience any problem you cannot easily rem- edy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor.

Please read and retain this manual. The instructions will enable you to assemble and maintain your tractor properly. Always observe the “SAFETY RULES”.

CUSTOMER RESPONSIBILITIES

•Read and observe the safety rules.

•Follow a regular schedule in maintaining, caring for and using your tractor.

•Follow the instructions under “Maintenance” and “Stor- age” sections of this manual.

WARNING: This tractor is equipped with an internal com- bustion engine and should not be used on or near any unimprovedforest-covered,brush-coveredorgrass-covered land unless the engine’s exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any). If a spark arrester is used, it should be maintained in effective working order by the operator.

A spark arrester for the muffler is available through your nearest authorized service center/department.

In the state of California the above is required by law (Section 4442 of the California Public Resources Code). Other states may have similar laws. Federal laws apply on federal lands.

TABLE OF CONTENTS

SAFETY RULES

2-3

PRODUCT SPECIFICATIONS

4

CUSTOMER RESPONSIBILITIES

4

ASSEMBLY

6-7

OPERATION

8-13

MAINTENANCE SCHEDULE

14

MAINTENANCE

14-17

SERVICE AND ADJUSTMENTS

18-23

STORAGE

24

TROUBLESHOOTING

25-26

WARRANTY

28

4

Page 3 Page 5
Image 4
Page 3 Page 5
Contents MODEL IMPORTANT MANUALOPERATORS MANUAL LAWN TRACTORSAFETY RULES Safe Operation Practices for Ride-OnMowersI. GENERAL OPERATION II. SLOPE OPERATIONIII. CHILDREN V. SERVICEIV. TOWING PRODUCT SPECIFICATIONS TABLE OF CONTENTSCUSTOMER RESPONSIBILITIES UNASSEMBLED PARTS Steering WheelSeat Slope SheetASSEMBLY TOOLS REQUIRED FOR ASSEMBLYTO REMOVE TRACTOR FROM CARTON BEFORE REMOVING TRACTOR FROM SKIDTO ADJUST SEAT See Fig CHECK TIRE PRESSURECHECK DECK LEVELNESS CHECK BRAKE SYSTEMOPERATION KNOW YOUR TRACTOR HOW TO USE YOUR TRACTOR TO SET PARKING BRAKE See FigSTOPPING See Fig TO USE THROTTLE CONTROL See FigTO ADJUST MOWER CUTTING HEIGHT See Fig TO ADJUST GAUGE WHEELS See FigREVERSE OPERATION SYSTEM ROS TO OPERATE MOWERBEFORE STARTING THE ENGINE TO OPERATE ON HILLSTO TRANSPORT See Fig TOWING CARTS AND OTHER ATTACHMENTSMOWING TIPS PURGE TRANSMISSIONMAINTENANCE GENERAL RECOMMENDATIONSMAINTENANCE SCHEDULEBATTERY TRACTORBLADE REMOVAL See Fig ENGINE TRANSAXLE MAINTENANCECLEAN AIR SCREEN V-BELTSCLEANING ENGINE COOLING SYSTEM See FigMUFFLER SPARK PLUGSSERVICE AND ADJUSTMENTS TO INSTALL MOWER See FigTO REMOVE MOWER See Fig G MF RG QG MF G A E TO LEVEL MOWER TO CHECK BRAKE TO REPLACE MOWER BLADE DRIVE BELT See FigTO REPLACE MOTION DRIVE BELT See Fig TO START ENGINE WITH A WEAK BATTERY See Fig TO ADJUST STEERING WHEEL ALIGNMENTFRONT WHEEL TOE-IN/CAMBER TO REMOVE WHEEL FOR REPAIRS See FigTRANSMISSION REPLACING BATTERY See FigTO REMOVE HOOD AND GRILL ASSEMBLY See Fig. REMOVAL/REPLACEMENTSTORAGE OTHERFUEL SYSTEM ENGINE OILTROUBLESHOOTING TROUBLESHOOTING POINTS ONLY RIDE UP AND DOWN HILL NOT ACROSS HILL 15 DEGREES MAXLIMITED WARRANTY
Top Page Image Contents