Poulan 96012008800, 425182 manual Engine dies when

Page 26

TROUBLESHOOTING POINTS

PROBLEM

CAUSE

CORRECTION

 

 

 

 

 

Engine dies when

1.

Reverse operation system

1.

Turn ignition key to

tractor is shifted

 

(ROS) is not "ON" while

 

ROS "ON" position.

into reverse

 

mower or other attachment

 

See Operation section.

 

 

is engaged.

 

 

 

 

 

 

 

Engine continues to run

1.

Faulty operator-safety presence control system.

1.

Check wiring, switches and connections. If not

when operator leaves seat

 

 

 

corrected, contact an authorized service center/

with attachment clutch

 

 

 

department.

engaged

 

 

 

 

 

 

 

 

 

Poor cut - uneven

1.

Worn, bent or loose blade.

1.

Replace blade. Tighten blade bolt.

 

2.

Mower deck not level.

2.

Level mower deck.

 

3.

Buildup of grass, leaves, and trash under mower.

3.

Clean underside of mower housing.

 

4.

Bent blade mandrel.

4.

Replace blade mandrel.

 

5.

Clogged mower deck vent holes from buildup of

5.

Clean around mandrels to open vent holes.

 

 

grass, leaves, and trash around mandrels.

 

 

 

 

 

 

 

Mower blades will not

1.

Obstruction in clutch mechanism.

1.

Remove obstruction.

rotate

2.

Worn/damaged mower drive belt.

2.

Replace mower drive belt.

 

3.

Frozen idler pulley.

3.

Replace idler pulley.

 

4.

Frozen blade mandrel.

4.

Replace blade mandrel.

 

 

 

 

 

Poor grass discharge

1.

Engine speed too slow.

1.

Place throttle control in “FAST” position.

 

2.

Travel speed too fast.

2.

Shift to slower speed.

 

3.

Wet grass.

3.

Allow grass to dry before mowing.

 

4.

Mower deck not level.

4.

Level mower deck.

 

5.

Low/uneven tire air pressure.

5.

Check tires for proper air pressure.

 

6.

Worn, bent or loose blade.

6.

Replace/sharpen blade. Tighten blade bolt.

 

7.

Buildup of grass, leaves and trash under mower.

7.

Clean underside of mower housing.

 

8.

Mower drive belt worn.

8.

Replace mower drive belt.

 

9.

Blades improperly installed.

9.

Reinstall blades sharp edge down.

 

10.

Improper blades used.

10.

Replace with blades listed in this manual.

 

11.

Clogged mower deck vent holes from buildup of

11.

Clean around mandrels to open vent holes.

 

 

grass, leaves, and trash around mandrels.

 

 

 

 

 

 

 

Headlight(s) not working

1.

Light switch is “OFF”.

1.

Turn light switch “ON”.

(if so equipped)

2.

Bulb(s) or lamp(s) burned out.

2.

Replace bulb(s) or lamp(s).

 

3.

Faulty light switch.

3.

Check/replace light switch.

 

4.

Loose or damaged wiring.

4.

Check wiring and connections.

 

5.

Blown fuse.

5.

Replace fuse.

 

 

 

 

 

Battery will not charge

1.

Bad battery cell(s).

1.

Replace battery.

 

2.

Poor cable connections.

2.

Check/clean all connections.

 

3.

Faulty regulator (if so equipped).

3.

Replace regulator.

 

4.

Faulty alternator.

4.

Replace alternator.

 

 

 

 

 

Engine “backfires” when

1.

Engine throttle control not set between half and

1.

Move throttle control between half and full speed

turning engine “OFF”

 

full speed (fast) position before stopping engine.

 

(fast) position before stopping engine.

 

 

 

 

 

26

Page 25 Page 27
Image 26
Page 25 Page 27
Contents PO18542LT ModelII. Slope Operation Safe Operation Practices for Ride-On MowersGeneral Operation IV. Towing ServiceIII. Children Table of Contents Contents of Hardware Pack Before Removing Tractor from Skid Tools Required for AssemblyTo Remove Tractor from Carton Unpack CartonCheck Battery See Fig Check for Proper Position of ALL Belts Check Tire PressureCheck Deck Levelness Check Brake SystemOperation Know Your Tractor HOW to USE Your Tractor To Operate on Hills Reverse Operation System ROSTo Operate Mower See Fig To TransportADD Gasoline Before Starting the EngineCheck Engine OIL Level To Start Engine See FigMowing Tips General Recommendations Maintenance ScheduleLubrication Chart Before Each USECheck Operator Presence System TractorBlade Removal See Fig Check Reverse Operation ROS SystemBelts BatteryEngine Transaxle CoolingAIR Filter CleaningClean AIR Screen MufflerTo Install Mower See Fig To Remove Mower See FigTo Level Mower Housing FRONT-TO-BACK Adjustment See FigsTo Check Brake Belt InstallationTo Replace Mower Blade Drive Belt See Fig To Replace Motion Drive Belt See FigTo Start Engine with a Weak Battery See Fig Transaxle Gear Shift Lever NEUTRAL- Adjustment See FigTo Adjust Steering Wheel ALIGN- Ment Front Wheel TOE-IN/CAMBERTo Adjust Carburetor To Adjust Throttle Control CableTo Adjust Choke Control To Replace Headlight BulbEngine OIL OtherFuel System CylindersTroubleshooting Points Problem Cause CorrectionEngine dies when Limited Warranty PoulanService Notes Only Ride UP and Down Hill Not Across Hill Degrees MAX Fold Along This Dotted Line Degree SlopeParts and Service Changere DE Pièces LES ET L’ENTRETIEN Degrés MAX Dentretien Notes Limitée Garantie Dépannage DE Guide Défectueux estRalenti Entreposage MoteurRéglages ET Révision Moteur19 .Fig Carrossage AVANT/ Roues DES ConvergenceTionrec -DI LA DE L’ALIGNEMENT Régler Pour Chan DE Levier DU Neutre AU RéglageCourroie Acer Rempl Pour Fig la Voir’EN Courroie LA Remplacer Pour DE Boîtier LE Niveau DE Mettre Pour SedeutonTracteur Fig la Voir Tondeuse LA Installer PourReglages ET Revision Tondeuse LA Enlever PourEntretien Trapézoïdales Courroies Transmission LA DE RefroidissementLubrification 10 .FIGFig la Voir Lame LA Enlever EN Fonctionnement DE Système ETLubrification DE Tableau Recommandations LESGénérales Utilisation Chaque AvantUtilisation Tonte DE Conseils’ESSENCE Réservoir LE Remplir Moteur LE Démarrer DE AvantMoteur LE Démarrer Pour Moteur DU D’HUILE Niveau LE VérifierTracteur LE Transporter Pour Accessoires AutresET Charrettes DES Remorquer Pour Pentes LES Dans Utiliser PourTeurtrac GAZ DES Commande LA Utiliser PourT O S I L I T U Reculer Pour ET Avancer Pour02829 Moteur Toutes SI Vérifier Toutes SI Vérifier MontageCorrectement Sont Courroies LES NI DE EST Tondeuse LA SI VérifierPalet LA DE Tracteur LE Retirer Pour Fig la Voir Batterie LA VérifierDesmancom des fonction la et Palette LA DU Tracteur LE Sortir PourLE Pour Exigés Outils LES ToncarMontar SIN Piezas Produit DE Spécifications SommaireClient DU Responsabilités Enfants EntretienRemorquage Général EntretienGénéral Fonctionnement PentesLES Dans Fonctionnement Tracteurs des sécurité toute en l’utilisation pour ConseilsAUX Imprimé

96012008800, 425182 specifications

The Poulan 425182,96012008800 is a highly regarded handheld leaf blower that serves the needs of both homeowners and professionals seeking efficient yard cleanup solutions. Known for its lightweight design and user-friendly features, this leaf blower is designed to make yard work less of a chore while enhancing productivity.

One of the standout features of the Poulan 425182 is its powerful engine. Equipped with a robust 25cc two-stroke engine, it delivers impressive airflow and speed, allowing users to tackle even the most stubborn leaves and debris with ease. The engine is designed for efficient fuel consumption, which means longer run times and less frequent refueling, a crucial factor for those tackling larger yards or extended jobs.

The ergonomic design of the Poulan 425182 means that it is comfortable to hold and operate for extended periods. Weighing in at just under ten pounds, it reduces user fatigue and allows for better maneuverability while working. This is particularly beneficial for those looking to clear large areas or navigate around obstacles like flower beds, trees, and outdoor furniture.

Another significant aspect of the Poulan 425182 is its variable speed control. This feature enables users to adjust the blower's power to suit the specific job at hand, whether it's light debris around flower beds or heavy leaf accumulation in corners of the yard. The variable speed not only enhances efficiency but also contributes to more precise cleaning.

The blower also incorporates a convenient cruise control feature that allows users to maintain a consistent airflow without needing to keep their finger on the throttle trigger. This adds to user comfort and provides a more enjoyable experience during lengthy tasks.

In terms of maintenance, the Poulan 425182 offers easy access to air filters and spark plugs, making it simpler to perform routine checks and ensure optimal performance. The two-stroke engine simplifies fuel mixing, and the reduced emissions technology helps to minimize environmental impact while still delivering the power needed for effective yard care.

In summary, the Poulan 425182,96012008800 leaf blower is a reliable tool that combines power, efficiency, and ease of use. Its lightweight design, ergonomic features, variable speed control, and low emissions technology make it a top choice for anyone looking to maintain their outdoor spaces effortlessly. For versatile and effective yard cleanup, this leaf blower stands out in the competitive market of outdoor power equipment.
Top Page Image Contents