Electrolux GT21L instruction manual Troubleshooting Table Cause Remedy

TROUBLESHOOTING TABLE

WARNING: Always stop unit and disconnect spark plug before performing all of the recommended remedies below except remedies that require operation of the unit.

TROUBLE	CAUSE		REMEDY
Engine will not	1. ON/OFF switch in OFF		1.	Move ON/OFF switch to ON position.
start.		position.	2.	See “Starting a Flooded Engine” in
	2. Engine flooded.
				Operation Section.
	3. Fuel tank empty.		3.	Fill tank with correct fuel mixture.
	4. Spark plug not firing.		4.	Install new spark plug.
	5. Fuel not reaching		5.	Check for dirty fuel filter; replace.
		carburetor.		Check for kinked or split fuel line;
				repair or replace.
	6. Carburetor requires		6.	See “Carburetor Adjustment” in
		adjustment.		Service and Adjustments Section.
Engine will	1.	Carburetor requires	1.	See “Carburetor Adjustment” in
not idle		adjustment.		Service and Adjustments Section.
properly.	2.	Crankshaft seals worn.	2.	Contact an authorized service dealer.
	3.	Compression low.	3.	Contact an authorized service dealer.
Engine will not	1.	Air filter dirty.	1.	Clean or replace air filter.
accelerate,	2. Spark plug fouled.		2.	Clean or replace plug
lacks power,	3.	Carburetor requires		and regap.
or dies under			3.	See “Carburetor Adjustment” in
a load.		adjustment.		Service and Adjustments Section.
	4.	Carbon build-up on	4.	Contact an authorized service dealer.
		muffler outlet screen.
	5.	Compression low.	5.	Contact an authorized service dealer.
Engine	1.	Choke partially on.	1.	Adjust choke.
smokes	2.	Fuel mixture incorrect.	2.	Empty fuel tank and refill with
excessively.	3.	Air filter dirty.		correct fuel mixture.
			3.	Clean or replace air filter.
	4.	Carburetor requires	4.	See “Carburetor Adjustment” in
		adjustment.		Service and Adjustments Section.
Engine runs	1. Fuel mixture incorrect.		1.	Empty fuel tank and refill with
hot.	2. Spark plug incorrect.			correct fuel mixture.
			2.	Replace with correct spark plug.
	3. Carburetor requires		3.	See “Carburetor Adjustment” in
		adjustment.		Service and Adjustments Section.
	4. Carbon build-up on		4.	Contact an authorized service dealer.
		muffler outlet screen.

YOUR WARRANTY RIGHTS AND OBLIGA- TIONS: The U. S. Environmental Protection Agency, Environment Canada and Jonsered are pleased to explain the emissions control system warranty on your year 2001--2004 small off--road engine. Jonsered must warrant the emission control system on your small off--road engine for the periods of time listed below pro- vided there has been no abuse, neglect, or im- proper maintenance of your small off--road en- gine. Your emission control system includes parts such as the carburetor and the ignition system. Where a warrantable condition exists, Jonsered will repair your small off--road engine

at no cost to you. Expenses covered under war- ranty include diagnosis, parts and labor.

MANUFACTURER’S WARRANTY COVER- AGE: If any emissions related part on your en- gine (as listed under Emissions Control Warran- ty Parts List) is defective or a defect in the materials or workmanship of the engine causes the failure of such an emission related part, the part will be repaired or replaced by Jonsered.

OWNER’S WARRANTY RESPONSIBILI- TIES: As the small off--road engine owner, you are responsible for the performance of the re- quired maintenance listed in your instruction manual. Jonsered recommends that you retain

9