CHANGING THE TRANSMISSION DRIVE BELTS
|
|
|
| Drive belt (Lower) | |
|
|
|
| ||
Pulley | Shift Lever |
| |||
|
| ||||
|
| ||||
|
|
|
|
| Drive belt (Upper) |
|
|
|
|
|
|
Belt Keeper
|
|
|
|
| Rear Idler Pulley | |
Battery Tray |
|
| ||||
Opening | Belt Keeper | Front Idler Pulley | ||||
|
|
|
|
| Keeper Pins | |
|
|
|
|
| ||
|
|
|
|
|
|
Engine Pulley
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| Double Idler Bracket |
|
| Electric PTO Clutch | ||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| ||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| ||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| |||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| Transmission Idler Pulley | Belt Keeper | ||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| ||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| ||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| ||||||
|
|
|
|
|
|
|
|
|
|
|
|
| Idler Bracket |
|
|
|
|
| |||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| ||||||||||||
|
|
|
| Transmission Pulley |
|
|
| ||||||||||||||||||||
Transmission |
|
|
|
|
|
|
|
Front of Tractor
NOTE: View shown from above tractor.
Figure 17
All belts on your tractor are subject to wear and should be replaced if any signs of cracking, shredding or rotting are present.
IMPORTANT: The
To change or replace the drive belt(s) on your tractor, proceed as follows:
NOTE: It’s recommended that both drive belts be replaced at the same time.
•Remove the cutting deck as instructed earlier in this section.
•After disconnecting the battery cables, remove the battery and battery tray from beneath the seat.
IMPORTANT: When removing the battery, disconnect the NEGATIVE (Black) wire from it’s terminal first, followed by the POSITIVE (Red) wire.
NOTE: Refer to Figure 2 in the TRACTOR
20