DeVillbiss Air Power Company D25572 warranty Storage, Generator Maintenance, Engine Preparation

Page 16

GENERATOR MAINTENANCE

Your generator should be kept clean and dry at all times. The generator should not be stored or operated in environments that includes excessive moisture, dust or any corrosive vapors. If these substances are on the generator, clean with a cloth or soft bristle brush. Do not use a garden hose or anything with water pressure to clean the generator. Water may enter the cooling air slots and could possibly damage the rotor, stator and the internal windings of the gen head.

(IF EQUIPPED) GROUND FAULT CIRCUIT INTERRUPTER GFCI RECEPTACLE)

MONTHLY: For maximum protection against electrical shock the GFCI should be tested monthly.

To test:

1.Depress the TEST button. The RESET button should extend. If the RESET button does not extend, notify a DeVilbiss Air Power Company Authorized Warranty Service Center.

2.To restore power, depress the RESET button firmly into the GFCI unit until an audible click is heard. If reset properly, the RESET button is flush with the surface of the test button. When the button stays in, the power is ON.

STORAGE

If you are going to store your generator for more than 30 days, use the following information as a guide to prepare the generator for storage.

Never store generator with fuel in the tank indoors or in enclosed, poorly ventilated areas, where fumes can reach

an open flame, spark or pilot light as on a furnace, water heater, clothes dryer or other gas appliances.

ENGINE PREPARATION

1.Add fuel stabilizer to fuel tank to minimize the formation of fuel gum deposits during storage.

2.Run engine at least 10 minutes after adding stabilizer to allow it to enter the fuel system.

3.Next shut off engine.

4.Disconnect the spark plug wire and remove the spark plug.

5.Add one teaspoon of oil through the spark plug hole.

6.Place rag over spark plug hole and pull the recoil a few times to lubricate the combustion chamber.

7.Replace the spark plug, but do not connect the spark plug wire.

NOTE: If a fuel stabilizer is not used, all gasoline must be drained from the tank and carburetor to prevent gum deposits from forming on these parts and causing possible malfunction of the engine.

GENERATOR

•Clean the generator as outlined in the Maintenance Section on this manual.

•Check that cooling air slots and openings on generator are open and unobstructed.

D25572

16- ENG

Page 15 Page 17
Image 16
Page 15 Page 17
Contents Generator Consumer General and Service Information Consumer Safety InformationSafety Guidelines / Definitions Important Safety InstructionsWhen installing a Double Risk of Electrocution and FireWhen damaged Risk of Electrocution and FireOperation Generator in rainUnit Indoors or in ANY Risk of FireConfined Area Risk of Breathing Inhalation Hazard Risk of Unsafe OperationRisk of HOT Surfaces Risk of Moving Parts Risk from LiftingAssembly Typical Installation of BatteryRemove Generator from Carton Grounding the GeneratorFor GBE4010 and GBFE6010 Obtaining Electricity from the Generator Double Throw Transfer SwitchExtension Cords Operation To Start the Engine Recoil start/Pull startConnecting Electrical Loads Stopping EngineMaintenance Engine MaintenanceCustomer Responsibilities Table General RecommendationsGenerator Maintenance StorageEngine Preparation GeneratorBattery Electric Start Units only Wattage CalculationsDetermining Wattage Requirements Starting WattsApplication Guide Starting Wattage RequirementsHousehold Wattage Calculator Appliance or Load Device Typical Device Wattage TotalTroubleshooting Guide StartLimited Warranty Responsibility of Original Purchaser initial UserQuick Facts Call 1-800-888-2468 EXT

D25572 specifications

DeVilbiss Air Power Company D25572 is a powerful air compressor that embodies cutting-edge technology and robust design, making it an invaluable asset for both professional and amateur users. Renowned for its reliability and performance, the D25572 is widely used in a variety of applications such as automotive tasks, woodworking, and home improvement projects.

One of the standout features of the D25572 is its impressive 6-gallon tank capacity, which allows it to store a substantial amount of compressed air and deliver consistent output without frequent cycling. This is particularly beneficial for users who require extended use of pneumatic tools, ensuring that they can complete tasks efficiently without interruptions for refilling.

Another key characteristic of the D25572 is its powerful 1.5-horsepower motor, which is designed to provide high airflow rates. This motor operates quietly and efficiently, reducing noise levels while still delivering sufficient power to meet demanding workloads. With a maximum pressure of up to 125 PSI, it can easily handle various tasks, from inflating tires to powering air tools.

The design of the D25572 emphasizes user-friendliness and portability. It features a compact, lightweight structure that makes it easy to transport from one job site to another. Additionally, the built-in handle enhances maneuverability, allowing users to move the unit without hassle. The unit also includes rubber feet, providing stability during operation and minimizing vibration.

Moreover, the D25572 incorporates several advanced technologies that enhance its functionality. The oil-free pump design eliminates the need for regular maintenance, making it an ideal choice for users seeking a low-maintenance solution. This feature not only saves time but also contributes to the overall durability of the unit.

The D25572 is equipped with multiple output ports, allowing for the simultaneous use of several air tools. This feature is especially useful for professionals who require versatility in their equipment. The compressor also comes with easy-to-read gauges, enabling users to monitor pressure levels accurately and make adjustments as needed.

In conclusion, the DeVilbiss Air Power Company D25572 air compressor combines efficiency, portability, and advanced technology, making it a top choice for various air-powered applications. Its robust features and user-centric design ensure that it meets the needs of both casual and professional users effectively.
Top Page Image Contents