ELECTRIC START WIRING
The generator is equipped with electric start. An
DC FEATURES
The charging system of the unit is supplied by the starter/alternator of the engine. 12 volts DC is constantly charging the battery when the unit is running . Disconnecting the battery will stop the charging of the battery.
Before charging a storage battery, check the electrolyte fluid level in all the cells. (Sealed batteries do not require checking). Add distilled water to each cell if necessary, to bring the level back up to the manufacturer’s required level.
WARNING: Storage batteries give off EXPLOSIVE hydrogen gas while charging. Do not allow smoking, open flames, sparks, or spark producing equipment in the area while charging.
WARNING: Battery electrolyte fluid is comprised of sulfuric acid that can be very dangerous and cause severe burns. Do not allow this fluid to contact eyes, skin, clothing, etc. If contact or spillage does occur, flush the area with water immediately.
CAUTION: This battery charging system is intended to recharge weak batteries, not to "boost start" vehicles. Do not overcharge battery or leave battery unattended.
CAUTION: Do not continue to charge a battery that becomes hot or is fully charged.
BATTERY INSTALLATION
Powermate Corporation recommends a 12 V battery with at least 235 cranking amps, Model U1L, Lawn and Garden Battery. Place the battery in the position provided. Place the spacers and washers on the bolts, then place the bolts through the loops on the
Spacers may be removed depending on the battery height.
WARNING: Batteries contain sulfuric acid (when filled). May contain explosive gasses. Always abide by safety warnings provided with the battery.
-Keep sparks, flame and cigarettes away.
-Hydrogen gas is generated during charging and discharging.
-Always shield eyes, protect skin and clothing when working near batteries.
Connect the red 8 ga. battery lead to the positive (+) battery post and the black 8 ga. battery to the negative
BATTERY KIT PARTS LIST
Item | Description | Qty. |
A. | *Bolt, | 2 |
B. | *Washer 1/4 | 2 |
C. | *Spacer | 2 |
D. | Hold Down bar (P/N 0036525.02) | 1 |
E. | *Nyloc nut, | 2 |
*These are standard parts available at your local hardware store.
|
|
|
English | 3 | |
|
|
|