Matsushita CF-52AJYZDZM service manual Setting the LCD Unit, Inverter Ass’y and Antenna PWB L, R

Page 55

9.2.21. Setting the LCD Unit, Inverter Ass’y and Antenna PWB L, R

1.Set the LCD Unit to the LCD Rear Cover

2.Fix the Inverter Ass’y using the Screw <N12>.

3.Fix the Anttena PWB L and R using the Screws <N2>.

LCD unit

	<N12>
	Cable	Tape
		Tape
	Inverter
	ass'y
	Cable	ANTENNA
		ANTENNA
		<N2> PWB L
	LCD rear cover	ANTENNA
	LCD rear cover	PWB R
		PWB R
		<N2>

4.Place the LCD Front on the LCD Rear Case. Confirm that the twenty-one Hooks are fixed perfectly.

5.Fix the LCD Front using the five Screws <N4> and two Screws <N15>.

6.Paste the LCD Screw Sheet and LCD Rubber.

	LCD	<N4>	LCD screw
LCD screw	rubber	<N4>	sheet
sheet		<N15>
		<N15>
			<N15> LCD
<N4>			rubber
<N4>		<N4>	<N4>
		<N4>	<N4>
		LCD screw
		sheet
		<N4>
			LCD front
Hooks			Hooks

Hooks

Hooks

Hooks Hooks

Screws <N2> : DFHE5122YA

Screw <N4> : DRHM0093ZA

Screws <N12> : DXSB2+4FNLT

Screws <N15> : XQN17+BJ6FJ

9-32

Image 55

Contents Model No. CF-52AJYZDZM Page Laser Safety Information Page Page Contents To check the model number SpecificationsCD/DVD Drive Wireless LAN Only for model with wireless LAN Microphone jack Names and Functions of PartsEX PC UFCBGA Diagnosis Procedure Troubleshooting Error Diagnosis by Checking Beep Signal Sound Power-On Self Test Boot CheckOutline of Post Stuck key 02D0 System cache error Cache disabled Self Diagnosis Test When you execute an automatic testOperation of PC-Diagnostic Utility Selection of tested device Test Item and Division of trouble GPS SW LED MDC PCB Wiring Connection DiagramLED PCB Disassembly/ReassemblyDisassembly Flowchart PAD PCB PWR BatteryRemoving the HDD PreparationHDD Mounting Kit DVD Multi DriveRemoving the Dimm Memory Card Removing the Robson Cover, Wireless LAN Module and BiosBios PCB Removing the Tilt Panl Ass’ySW LED MDC PCB Wireless LAN ModuleBios PCB Removing the Display unitAntenna Removing the LCD unit, Inverter Ass’y and Antenna PWB L,RRemoving the Handle Assy LCDRemoving the Keyboard Removing the ModemSpeaker R Speaker LRemoving the Pad and Touch PAD PCB Removing the Top CoverRemoving the SD PCB Removing the Audio PCB Removing the PWR Battery LED PCBPWR Battery LED PCB Wwan PCB Removing the Wwan PCBKBD Earth Plate CN7 Removing the KBD Earth PlateRemoving the Hinge Support R Removing the Fan Ass’yRemoving the Heat Sink Ass’y Removing the Battery Connector Ass’yRemoving the Hinge Support L and MP Hold Plate Removing the SC Relay PCB and HDD Hold PlateCN4 Main High PCB Removing the Serial PCBRemoving the Main High PCB Serial PCBSetting the Main High PCB Reassembly InstructionsSetting of Main PCB before assembling Page Setting the Heat Sink Ass’y Setting the Serial PCBSetting the Fan Ass’y Page Setting the SC Relay PCB and HDD Hold Plate Setting the Hinge Support L and MP Hold Plate Setting the Battery Connector Ass’ySetting the Hinge Cover R KBD Earth Plate Setting the KBD Earth PlatePWR Battery LED PCB Setting the PWR Battery LED PCBSetting the Audio PCB Setting the Wwan PCB Setting the Pad and Touch PAD PCB Setting the SD PCBSetting the Top Cover Setting the Keyboard Page Setting the Modem Setting the SpeakersHow to paste the Tape Setting the Handle Ass’y Setting the LCD Unit, Inverter Ass’y and Antenna PWB L, R Shield Sheet B LCD Damper CAdhesive Tape B Adhesive Tape a Tape Sheet Page Setting the Display Unit, Bios High PCB and SW LED MDC PCB Arranging the Cables when assembling the LCD Unit Page Setting the Wireless LAN Module, Bios PCB and Robson Cover Setting the Tilt Panel Ass’y Setting the Dimm Memory Card and Dimm CoverScrew N202 DRSB2+4FKLT Setting the HDD Screw tightening torque Exploded ViewCF-52AJYZDZM DM4 DM1DM5 DM2 DM7K14 K26 E16 E16-2 RTL Replacement Parts ListNRP Mechanical Parts DFHR3G78ZA FIN Duct DFHE1089ZA DM3 DM2DM6 EEFCX0D221R CPUChipset PM ChipsetRESISTOR, 1/16W, 0Ω EEFCX0J101R ConnectorCONNECTOR, USB EEFUD0J151ERIC, Switch Temperature SensorIC, FET Switch IC, USB Power SWInductor IDUCTOR, Common Mode FilterSwitch JackRESISTOR, 1/16W, 1Ω RESISTOR, 1/16W, 10KΩRESISTOR, 1/16W, 20KΩ RESISTOR, 1/16W, 3KΩRESISTOR, 1/16W, 10MΩ JumperRESISTOR, 1/16W, 47KΩ RESISTOR, 1/16W, 18KΩ RESISTOR, 1/16W, 15KΩRESISTOR, 1/16W, 33KΩ RESISTOR, 1/16W, 16KΩAudio Codec IC, Audio Power AmplifierEVQPLDA15 Switch ECUV1H103ZFG InductorIC, DC/DC Converter DIP SwitchBluetooth Module DEDRB081L20 DiodeChip Inductor