LG Electronics TL-AT130M service manual Mechanism Troubleshooting Guide

Page 60

MECHANISM TROUBLESHOOTING GUIDE

1.Deck Mechanism

A.

Auto REW doesn't work.

YES

Is the output of END sensor of

supply side "H"?

“H”: more than 3.5V

“L”: less than 0.7V~1V

NO

YES

NO

Is the Vcc. voltage of End

sensor 5V?

YES

Replace the End sensor.

NO

Is the voltage across IR LED

Replace the IR LED.

between 0.8~1.5V?

Check the syscon power.

YES

Check the syscon circuit.

B.

No F/R modes.

YES

Is the present mode

F/R Mode?

NO

Is the mode SW assembled correctly? (refer to page 4-13.)

YES

Does the Capstan Motor rotate?

YES

Do the T/Up, Supply Reel rotate?

YES

Check the syscon circuit.

NO

Is the normal voltage supplied to the Capstan Motor Vcc1, Vcc2?

YES

Does terminal voltage(Vctl) of Capstan Motor supply side more than 4V?

YES

Replace the Capstan Motor.

NO

Check the servo, power circuits.

4-23

Image 60

Contents KEY Table of Contents Summary Front RearIndicator Panel VCR Function IndicationTerminal Signal Levels IN/OUT DescriptionSummary Critical Parts Replacing Time Table Cabinet & Main Frame Exploded Views Cabinet & Main Frame Section Parts list Cabinet and Main Frame SectionPacking Accessory Section Parts list Packing & Accessory SectionPG Adjustment Connection chart of PG adjustmentPower CircuitSMPS No 5.3 a No 24No 5.2 a to AVCP, Bias Video is unstable in PB mode PB modeWhen the drum moter stop Servo CircuitWhen the capstan motor stops Capstan motor stopsNo Video in EE Mode No Video in EE ModeC Circuit Clean the Drum Check the System Circuit IC501 Pin Pin 16, 40, 55, 58, 87?Is the EE signal normal? Is 5V applied to the IC301 Pin 16, 40, 55, 58, 87?No sound in EE Mode No sound in PB Mode No sound in EE ModeNo sound in PB Mode Audio CircuitNo sound in REC Mode No sound in REC ModeSYSTEM/KEY Circuit Auto Stop No cassette tape loadingAuto Stop No Key display OSD CircuitNo OSD display No F.OSD displayElectrical Block & Circuit Diagrams Power Block Diagram Power Clrcuit Diagram Audio Block Diagram C Block Diagram V Circuit Diagram Electrical Block & Circuit Diagrams System Block Diagram Electrical Block & Circuit Diagrams System Clrcuit Diagram Jack Clrcuit Diagram KEY-BOARDCLRCUIT Diagram Electrical Printed Circuit Diagrams KEY 1 P.C.BOARD KEY 2 P.C.BOARD Jack P.C.BOARDMechanism Top View Bottom View Part Fixing TypeDrum Assembly Fig. A-1-1 Drum MotorPlate Top Fig. A-2-1 Fig. A-2-4Gear Assembly Rack F/L Fig. A-2-5 Holder Assembly CST Fig.A-2-2Bracket Assembly L/D Motor Fig. A-2-4 Arm Assembly F/L Fig. A-2-6Arm Assembly CleanerBase Assembly A/C Head Head F/E Fig. A-3-2Brake Assembly T Fig. A-4-1 Brake Assembly RS Fig. A-4-2Arm Assembly Tension Fig. A-4-3 Reel S / Reel T Fig. A-4-4Arm Assembly Pinch Fig. A-5-3 Opener Lid Fig. A-5-2Lever T/up Fig. A-5-4 Arm T/up Fig. A-5-5 Brake Assembly Capstan Lever F/R Fig. A-6-3Gear Sector Fig. A-7-3 Lever Tension Fig. A-7-5Lever Spring Fig. A-7-6 Just lift the Plate Slider upGear Assembly P2 Fig. A-8-1/ Gear Assembly P3 Fig. A-8-2 Base Assembly P2 Fig. A-8-3/ Base Assembly P3 Fig. A-8-4Base Loading Fig. A-9-1 Arm Assembly Idler Fig. A-9-3 Arm Assembly IdlerBase Tension Fig. A-9-2 Base Tension Base LoadingDeck Mechanism Adjustment Mechanism Alignment Position Check Fig. C-1Checking Torque Test Equipment/ Fixture Test ConditionsMechanism Condition Torque Gauge 600g.cm ATG Cassette Torque Meter SRK-VHT-303Guide Roller Height Adjustment Audio/Control A/C Head Adjustment Adjustment Procedure/DiagramsHead Assembly Head BaseValue Adjustment Precise Adjustment Azimuth adjustmentAdjustment Procedure Adjustment Diagram 1KHZ 7KHZAdjustment after Replacing Drum Assembly Video Heads Check the Tape Travel after Reassembling Deck AssemblyCheck before starting repairs Required Maintenance Scheduled MaintenanceMaintenance Procedure CleaningGreasing Chassis Bottom Chassis TopGear Sector Gear Cam Base Loading Gear Drive Lever, F/R, Base, Tension Gear AY, P2 & P3Base, Tension Mechanism Troubleshooting Guide Auto Stop PLAY/CUE/REV Nono Is the Belt ok?Front Loading Mechanism Cassette does not load Exploded Views Moving Mechanism A11 NSP Not Service Part RUN DateParts Section Description Specification Assembly Section RemarksLOCA.NO Description Specification Remarks ScrewLOCA.NO Description Specification Remark BATTERY,LITHIUM Electrecal sectionBuzzer CapacitorLOCA.NO Description Specification Remark NP0 TS Coil DiodeDigitron FilterFuse HolderR121 0RD1800F608 R3G6 0RD1800F608 R553 0RD2200F608 R610 0RD2701F608 LOCA.NO Description Specification Remote Controller Receiver RemarkSwitch RESISTOR,DRAWINGTransformer VaristorTAL Zener Diode