Mitsubishi Electronics WD-62628, WD-52628, WD-73727 AIR Filter Cleaning, Lamp Cartridge Air Filter

Page 44

is blocked.”

SERVICE MANUAL SUPPLEMENT

MODELS

WD-62827 / WD-62927

AIR FILTER CLEANING

If the TV shuts off after displaying the message “TV will shut down in a few seconds. Please check if the air flow and/or the Status LED is yellow, the Air Filter may need cleaning. The Air Filter is part of the

Lamp Cartridge. Use the following steps for filter cleaning.

1)Refer to the Owner’s Guide to remove the Lamp Cartridge. Be sure to observe all cautions.

2)Holding the Lamp Cartridge filter side down, use a soft dry brush or vacuum cleaner to remove any dust that may be present. Note: Do not use any liquids.

3)Reinstall the Lamp Cartridge.

Keeping the air filter clean will help prevent the lamp from overheating.

Hold Lamp Cartridge filter side down and remove dust using a soft dry brush or vacuum cleaner.

Lamp Cartridge - Air Filter

COPYRIGHT © 2007 MITSUBISHI DIGITAL ELECTRONICS AMERICA, INC.

ALL RIGHTS RESERVED

Image 44

Contents V29 / V30 / V30+ / V31 Chassis SpecificationsMitsubishi Digital Electronics AMERICA, INC Page Contents Schematic Diagrams Servicing use only recommended Lead-Free solder refer to Product Safety NoticeIntroduction Safety Precautions Leakage current checkCabinet Front Disassembly WD-52627 / WD-52628 / WD-62627 / WD-62628Speaker Grille & Bezel Removal SCREEN-ASSY RemovalWD-62827 Front Disassembly Front Panel Caps RemovalSIDE-TRIM Removal Bezel RemovalScreen Assy Removal WD-62927 Front Disassembly TOP, Bottom and Sides Trim Removal Front Bezel Removal Screen Assembly Removal WD-73727 / WD-73827 Front Disassembly Card Reader RemovalGRILLE-SIDE Removal WD-73927 Front Disassembly SCREEN-ASSY Removal Cabinet Rear Disassembly BACK-COVER RemovalChassis Disassembly / Accessing PWBs Chassis Sequence of DisassemblyChassis Removal from the cabinet Figure aChassis Cover Removal Figure Assy PWB- Terminal Removal FigurePWB-POWER Removal Figure Chassis Upper Shield Removal FigurePWB-MICRO Removal PWB-FORMAT & PWB=RISER Removal Referring to FiguresPWB-DM Removal Chassis Rear Shield Removal Figure PWB-DM Removal FiguresCE1 Operating Chassis Outside of CabinetPCPA1 Bolt Table Optical Engine Replacement 52 & 62 Models Optical Engine Replacement Details Ltjc52 & 62 Optical Engine Replacement Details CJ352 & 62 Optical Engine Replacement Details Spring Model’s Optical Engine Replacement ENGINE-PWR-PWBModels Optical Engine Replacement Details Engine Assembly removal from the cabinetCd c Lamp Cover VerticalEngine removal from the Base Plate Assembly Joining e BracketRubber GWedge Unplug Ballast LeadsAfter Replacing the Optical Engine Engine InstallationDo not Lose To Remove the Diamond Shield To Install the Diamond ShieldWD-62927 / WD-73927 Only Servicing the Lenticular Screen and Fresnel Lens Lenticular Screen and Fresnel Lens RemovalLenticular Screen and Fresnel Lens Installation Option Menu LED Indicator Diagnostics InputsAbnormal LED Indications AIR Filter Cleaning Lamp Cartridge Air FilterMeasuring equipment and Jigs Test signalCircuit Adjustment Mode Resetting Data to Factory Values Adjustment SelectionAdjusting Data Terminating the circuit adjustment modeRequired Tools PrelminaryWD-52627 / 62627 / 52628 WD-62827AAdjustment Access Pedestal Cover Locking Screws and Wedge Removal 52 & 62 Side Locking ScrewLocking Screws Adjustment ProceduresAdjustment Locations Rotation Adjustment Horizontal Keystone AdjustmentVertical Keystone Adjustment After AdjustmentDisplays used to indicate Pb-free Pb-Free DisplayChip Parts Removal Transistors ReplacementChip Parts Removal Resistors, Capacitors, etc Parts Tolerance Codes Critical and Warranty Parts DesignationParts Ordering Quick Reference for Common Parts Integrated Circuits Transistors DiodesCoils EMI-F-CHIP BLM11A601S COIL-CHIP 33MH-JCOIL-CHIP 10MH-K COIL-CHIP 10MH-JEMI-F-CHIP BLM11B050SA COIL-RF 22MH-K COIL-RF 6.8MH-MCOIL-RF 10MH-K COIL-RF 2.7MH-MTransformers ResistorsEMI-F-CHIP NFL21SP506X13CD CHIP-FILTER ACM2012D-9002PMETAL-P 3W 1K-J CapacitorsTHRM-CHIPNCP18XH103F03RB Switches MiscellaneousSW-LEVER TAPE-LENS2RF-SWITCH SWITCH-RF-TYPEPlate RF-SWITCH Button ResetAccessories Cosmetic Parts491P178040 SCREEN-LENTICULAR 598D822010 Screen Bracket 623D224010 SCREEN-FRAME Spacer491P178030 SCREEN-LENTICULAR 598D683010 Screen Bracket 623D224010 SCREEN-FRAME Spacer598D683010 Screen Bracket WD-62827 Screen Parts FigureWD-62927 Screen Parts Figure WD-73727 Screen Parts Figure WD-73827 Screen Parts FigureWD- 73927 Screen Parts Figure 491P176050 SCREEN-LENTICULARPage Main Power Supply Lamp Ballast DC Supply Fans Power Supply Page Analog Video Signal Path Digital Video Signal Path Signal Path V31 Only HDD Record V30+ Sound Signal Path Command Input Circuitry Serial Control Lines Lamp Control Circuitry Page Reader Live To Shutter Control IC3J01 PWB-SWLAMP

Related manuals

Manual 124 pages 10.19 Kb

Manual 118 pages 1.3 Kb

Manual 128 pages 42.7 Kb