Simplicity TP 400-2218-00-SV-SMA manual Housing, Trunnion, Cylinder Block KIT

Page 59

Hydrostatic Pump (Service Parts for 1671582 - Hydro Lift)

REF NO.	PART NO.	QTY.	DESCRIPTION
1	1652181	1	BEARING, Ball
2	1673534	1	HOUSING
3	1652192	2	RING, Retainer
4	1652194	1	TRUNNION
5	1652235	2	WASHER, Special
6	1652234	2	SEAL, Lip
7	1652251	2	BEARING, Needle
8	1652185	2	PIN, Headless, Straight
9	1612093	2	SEAL, Lip
10	1652231	1	BEARING, Ball
11	905123	1	KEY, Woodruff
12	1652229	1	SHAFT, Pump
13	1652228	1	PIN, Headless
14	1673533	1	PLATE, Swash
15	1673532	2	PLATE, Thrust
16	1652226	3	PIN, Spring, Coiled
17	1652186	1	SHAFT, Motor
18	1652184	1	GASKET
19	1652183	1	TRUNNION
20	1673535	2	CYLINDER BLOCK KIT
21	1652223	1	PLATE, Valve, Pump
22	1652224	2	PIN, Straight
23	1652189	1	PLATE, Valve, Motor
24	1652222	2	BEARING, Needle
25	1652221	2	O-RING
26	1652220	2	RING, Backup
27	1652219	2	O-RING
28	1652217	2	PLUG, Hex Hd.
29	921884	2	O-RING
30	1652216	4	SHIM (Shim as required)
31	1652214	2	CONE, Relief Valve
32	1667773	1	SPRING, Relief Valve
33	1667774	1	RELIEF VALVE KIT (Incl. Ref. Nos. 28-32)
34	1685128	1	CHARGE PUMP KIT (Incl. Ref. Nos. 36-40)
35	1652212	2	CAPSCREW, 12 pt.
36	1652207	1	O-RING
37	*	1	GEROTER (See Ref. No. 34)
38	*	1	HOUSING, Charge Pump (See Ref. No. 34)
39	1652204	1	BEARING, Needle
40	1652203	1	SEAL, Lip
41	1927531	2	CAPSCREW, Hex Hd, 7/16-14 x 2
42	1918199	2	WASHER
43	1671665	1	PLUG
44	1652196	2	O-RING
45	1671699	1	UNION, Filter
46	1652197	2	PLUG, Hex Hd.
47	1923701	4	CAPSCREW, Hex Hd, 3/8-16 x 2
48	1652254	1	SECTION, Center
49	1709322	1	FILTER, 25 Micron

Footnotes:

* Not serviced separately.

Note: Items 50-61 listed on following page.

The above parts group applies to the following Mfg. Nos.:

1692796	Sov 18HP Hydro	1692889	Sov 75 Anv 18HP OHC Hydro	1692955	2818H, 18HP OHC Hydro	1693411	918H, 18HP OHC Hydro PS
1692798	Sov 18HP Hydro PS	1692943	Sov 18HP OHC Hydro PS	1693144	Sov 18HP OHC Hydro-Exp	1693413	918H, 18HP OHC Hydro
1692845	918H, 18HP Hydro	1692945	Sov 18HP OHC Hydro	1693146	Sov 18HP OHC Hydro PS-Exp	1693415	2818H, 18HP OHC Hydro PS
1692847	918H, 18HP Hydro PS	1692949	918H, 18HP OHC Hydro PS	1693148	Sov 75 Anv 18HP OHC-Exp	1693417	2818H, 18HP OHC Hydro
1692849	2818H 18HP Hydro	1692951	918H, 18HP OHC Hydro	1693407	Sov 18HP OHC Hydro PS
1692852	2818H, 18HP Hydro PS	1692953	2818H, 18HP OHC Hydro PS	1693409	Sov 18HP OHC Hydro

TP 400-2218-00-SV-SMA

57

Image 59

Contents Sovereign / 900 N U F a C T U R I N G , I N C Spring Street / PO Box Table of Contents SV43001A Frame & Footrest GroupFOOTREST, L.H LOCKWASHER, 7/16LOCKWASHER, 5/16 BushingSV43002A Front Axle GroupWasher Spindle ASSEMBLY, LHSpindle ASSEMBLY, RH SpacerSV43003A Manual Steering GroupBalljoint Ring1916951 NUT, Hex, Full, 1/2-13 1916966 LOCKWASHER, 1/2Steering Torque to 16-24 ft. lbs Cylinder Seal Kit Power Steering GroupCylinder Seal Repair KIT Ball Joint Assembly1679556 1679538SV43005A Engine, Exhaust & Drive Shaft Group Kohler 18HP OHVChoke Control Heat Shield AssemblyShut OFF Valve FittingThrottle Control Plate Engine, Exhaust & Drive Shaft Group Kohler 18HP OHC1930598 CAPSCREW, Hex Washer Hd, Taptite, 3/8-16 x 1932771 Drive Shaft Assembly157424 WASHER, Special 173026 1920415 CAPSCREW, Hex Hd, 3/8-16 x 1-1/4 1717111SV43007A Clutch & Brake GroupSpring BracketWASHER, 3/8 PulleySV43008A Clutch & Brake Control Group1650531 ROD, Clutch 121037 Guard AssemblyROD Assembly Hydrostatic Pump Group See Pages 56-59 for Service PartsFilter Assembly SV43010A Hydrostatic Control GroupQuadrant Shaft AssemblyLOCKWASHER, 1/4 LinkSV43011A Transmission GroupPinion Pinion & Shaft AssemblyBearing GasketSV43012A PTO Control & Cone Clutch GroupLever Handle AssemblyPivot Assembly Bearing AssemblySV43013A Hydraulic Lift GroupPIN Lever AssemblySupport Assembly Cable AssemblySV43014A Bevel Gear & Side Plate GroupLOCKWASHER, 1/4, I.D Plug AssemblyShim CoverSV43015A Draw Bar GroupPlate 166072 BAR ASSEMBLY, Upright 1661101923027 CAPSCREW, Hex Hd, 7/16-14 x 1-3/4 1918199 166075SV43016A Rear Axle & Differential Group930671 KEY, Hi-Pro 153068 Differential sub-assembly 1650519 includes these parts162085 SV43017A Electrical Group Early ModelsAmmeter Harness AssemblyWire Assembly Headlight AssemblySV43018A Electrical Group Later ModelsNot Serviced Separately Supplied by Engine Manufacturer 1714647 Cable Battery to Ground 1717183SV43019A Dash, Hood & Grille Group Manual Steering ModelsScreen Dash AssemblyPush NUT SV43020A Dash, Hood & Grille Group Power Steering Models1960517 LOCKNUT, Pal Hood & Grille Assembly1931333 Carriage BOLT, 5/16-18 x 3/4 1708749 D8 E Seat & Deck Group Early Models1693144 Sov 18HP OHC Hydro-Exp SV43022A Seat & Deck Group Later ModelsSeat 1718851SV43023A Tire & Wheel GroupNot serviced separately Optional To Avoid Injury Decals Safety & CommonDECAL, USA 1708927SV43025A Decals Brand & ModelDecals Brand & Model EE ED 75th Anniversary Specialty PartsVisor SET Hood AssemblyHEADLIGHT-REAR Worklight Assembly Clamp Assembly SV43027A Power Steering Valve Service PartsRotor Assembly KIT Upper Cover Assembly KITMetering Assembly KIT Commutator & Ring Assembly KITSV43028A Hydrostatic Pump Service Parts for 1671582 Hydro LiftCylinder Block KIT HousingTrunnion Hydrostatic Pump Service Parts for 1671582 Hydro Lift Check Valve SV43029A Control Valve Service PartsWiper Plug Control Valve Group Service PartsCAP Assembly PlungerSV43030A Mower Deck Housing & Arbor GroupLockwasher 3/8 Pulley AssemblyBracket & Shaft Assembly RollerSV43031A Mower Deck Cover, Drive & Bail GroupEyebolt Bail AssemblyYoke SV43032A Mower Deck Height Adjusting & Roller GroupPivot Rocker ARM AssemblySocket Assembly GripSV43033A Mower Deck Deflector, Stone Guard & Arm Assembly Group1921176 CAPSCREW, Hex Hd, 1/2-13 x 1-1/4 1916966 Not serviced176012 PIN, Clip 172468 Part No. Page No Ref No Part Number Index by Page NumberPart Number Index by Page Number Part Number Index by Page Number Part Number Index by Page Number DIA Hardware Identification & Torque Specifications