Razor 25143511 owner manual Troubleshooting Guide, Battery Care and Disposal, Charger

Repair and Maintenance

qBattery Care and Disposal

Do not store the battery in temperatures above 75° or below -10° F.

CONTAINS SEALED LEAD ACID BATTERIES. BATTERIES MUST BE RECYCLED.

Disposal: Your Razor product uses sealed lead-acid batteries which must be recycled or disposed of in an environmentally safe manner. Do not dispose of a lead-acid battery in a fire. The battery may explode or leak. Do not dispose of a lead-acid battery in your regular household trash. The incineration, land filling or mixing of sealed lead- acid batteries with household trash is prohibited by law in most areas. Return exhausted batteries to a federal or state approved lead-acid battery recycler or a local seller of automotive batteries. If you live in Florida or Minnesota, it is prohibited by law to throw away lead-acid batteries in the municipal waste stream.

qCharger

The transformer/charger supplied with the Dune Buggy should be regularly examined for damage to the cord, plug, enclosure and other parts, and, in the event of such damage, the bike must not be charged until it has been repaired or replaced.

Use ONLY with the recommended charger.

qReplacement Parts

The most frequently requested replacement parts (wheels, tires, tubes, batteries and chargers) are available for purchase at some Razor retail partners. For the complete selection of replacement parts visit www.razor.com/shop.

qRepair Centers

For a list of authorized Razor repair centers:

•Check online at www.razor.com.

•Call 866-467-2967 for the center nearest you.

WARNING: If a battery leak develops, avoid contact with the leaking acid and place the damaged battery in a plastic bag. Refer to the disposal instructions at left. If acid comes into contact with skin or eyes, flush with cool water for at least 15 minutes and contact a physician.

WARNING: Battery posts, terminals and related accessories contain lead and lead compounds. Wash your hands after handling.

Troubleshooting Guide

Problem	Possible Cause	solution
Product does not run.	Product is rolling backwards.	Throttle will not engage if the product is rolling backwards. Come to
		a complete stop and then activate the throttle.
	Undercharged battery.	Charge the battery. A new battery should have been charged for at
		least 18 hours before using the product for the first time and up to 12
		hours after each subsequent use.
		Check all connectors. Make sure the charger connector is tightly
		plugged into the charging port, and that the charger is plugged into a
		functioning wall outlet.
	Charger is not working.	You may check to see if your charger is working by using a volt meter
		or asking your local Razor authorized service center to test your
		charger for you.
Product was running but	Loose wires or connectors.	Check all wires and connectors to make sure they are properly
suddenly stopped.		connected.
	Burned-out fuse.	The fuse will burn out and automatically shut off the power if the
		motor is overloaded.
		An excessive overload, such as too heavy a rider or too steep a hill,
		could cause the motor to overheat. Refer to page 3 - “replacing the
		fuse”. Correct the conditions that caused the fuse to burn out and
		avoid repeatedly burning out fuse.
		Contact your local Razor authorized service center for diagnosis and
		repair. Contact Razor customer service or visit www.razor.com

4