2.With the help of a second person, carefully lower the treadmill frame and then tip the Uprights (69) down as shown. (Note: It may be helpful to place your foot on one of the Extension Legs [63] as you tip the Uprights.) Make sure that the Extension Legs remain in the Uprights.
Attach each Extension Leg (63) with two 3/4” Tek Screws (58).
Attach four Base Pads (57) with 3/4” Tek Screws (58) as shown.
Note: One replacement Base Pad (57) may be included. If a Base Pad becomes worn and needs to be replaced, use the replacement Base Pad.
3.With the help of a second person, raise the Uprights (69) to the vertical Position. Attach the Storage Latch (36) to the left Upright with two 3/4” Screws (2). Remove the Latch Knob (30) from the Latch Pin (35). Make sure that the Latch Pin Collar (33) and the Spring (32) are on the Latch Pin as shown. Insert the Latch Pin into the Storage Latch, and tighten the Latch Knob back onto the Latch Pin.
4.Identify the Right Handrail (72), which has a large hole in the left side. Feed the Wire Harness (42) up into the bracket on the Right Handrail and out of the large hole in the left side. (Note: It may be helpful to use needlenose pliers to pull the Wire Harness out of the large hole.) Press a Handrail Cap (76) onto the lower end of the Right Handrail as shown.
Insert the bracket on the Right Handrail (72) into the top of the right Upright (69) so the Handrail Cap (76) is rest- ing against the Upright. Attach the Right Handrail and the Handrail Cap with three 1” Bolts (37) and two Washers
(38)as shown. Firmly tighten the indicated Bolt, but do not tighten the other Bolts yet.
Attach the Left Handrail (not shown) as described above. Note: There is not a wire harness on the left side.
2 |
|
|
|
57 |
|
|
|
58 |
|
|
|
58 |
| 58 |
|
| 57 |
| |
|
|
| |
57 | 63 |
|
|
|
|
| |
58 |
|
|
|
|
| 58 | 69 |
|
| 57 | 63 |
|
| 58 |
|
3 |
|
|
|
30 | 36 | Large |
|
Hole |
| ||
|
| ||
|
| 32 |
|
2 |
| 33 |
|
|
|
| |
|
|
| 35 |
|
| 69 |
|
4 | 42 |
|
|
Large
Hole 
Bracket | 37 |
38
72
37
69
38
Tighten
76 37 
7