Razor MX650 15165070, MX350 15128050, MX500 15128190 owner manual Troubleshooting Guide

Page 12

Troubleshooting Guide

Problem

Possible Cause

solution

Vehicle does not run

Undercharged battery

Charge the battery. A new battery should have been charged for at

 

 

least 12 hours before using the vehicle for the first time and up to 8

 

 

hours after each subsequent use.

 

 

Check all connectors. Make sure the charger connector is tightly

 

 

plugged into the charging port, and that the charger is plugged into

 

 

the wall.

 

 

Make sure power flow to the wall outlet is on.

 

Charger is not working

You may check to see if your charger is working by using a volt meter or

 

 

asking your local Razor authorized service center to test your charger

 

 

for you.

 

Loose wires or connectors

Check all wires and connectors to make sure they are tight.

Vehicle was running but

Burned-out fuse

suddenly stopped

 

Motor or electrical switch damage

The fuse will burn out and automatically shut off the power if the motor is overloaded.

An excessive overload, such as too heavy a rider or too steep a hill, could cause the motor to overheat. Replace the fuse with a new one of equal amperage. Correct the conditions that caused the fuse to burn out and avoid repeatedly burning out fuse.

Contact your local Razor authorized service center for diagnosis and repair.

Short run time (less than

Undercharged battery

30 minutes per charge)

 

Battery is old and will not accept full charge

Charge the battery. A new battery should have been charged for at least 12 hours before using the vehicle for the first time and up to 8 hours after each subsequent use.

Check all wires and connectors. Make sure the battery connector is tightly plugged into the charger connector, and that the charger is plugged into the wall.

Make sure power flow to the wall outlet is on.

Even with proper care, a rechargeable battery does not last forever. Average battery life is 1 to 2 years depending on vehicle use and conditions. Replace only with a Razor replacement battery.

 

Brakes are not adjusted properly

Refer to brake adjustment instructions on page 5 of this manual.

 

 

 

Vehicle runs sluggishly

Driving conditions are too stressful

Use only on solid, flat clean and dry surfaces such as pavement or

 

 

level ground.

 

Tires are not properly inflated

The tires are inflated when shipped, but they invariably will lose some

 

 

pressure between the point of manufacturing and your purchase. Refer

 

 

to instructions on page 4 and 5 of this manual to properly inflate tires.

 

Vehicle is overloaded

Make sure you do not overload the vehicle by allowing more than

 

 

one rider at one time, exceeding the maximum weight limit, going up

 

 

too steep a hill or towing objects behind the vehicle. If the vehicle is

 

 

overheated, the temperature circuit protector will slow motor down

 

 

and if the condition continues, will shut off power to the motor. Correct

 

 

the driving conditions that caused the overheating, wait 5-10 minutes

 

 

and then resume riding. Avoid repeatedly overheating the unit.

 

 

 

11

Page 11 Page 13
Image 12
Page 11 Page 13
Contents Read and understand this entire manual before riding Contents Safety WarningsEstimated Assembly and Set-Up Time Before You BeginRequired Tools Assembly and Set-Up Charging the BatteryAttaching the Front Forks MX350 Installing the Front Wheel MX500 / MX650 Attaching the HandlebarsAttaching the Front Fender and Number Plate Repair and Maintenance Testing the BrakesAdjusting the Brakes MX350 Inflating the TiresChain and Rear Tire Replacement MX350 Chain and Tire Replacement MX500 / MX650 Replacing the Fuse MX350 / MX500 / MX650 QChecking Spoke Tension MX500 / MX650Battery Care and Disposal Replacement Parts Repair CentersChain and Sprocket ChargerSB 1918 California Declaration Troubleshooting Guide Sometimes the vehicle Loose wires or connectors Vehicle does not stop Brakes are not adjusted properlyRepair Charger gets warm Normal response to charger useMX350 Parts MX350 Parts MX500 / MX650 Parts MX500 / MX650 Parts Safety reminders Warranty

MX500 15128190, MX650 15165070, MX350 15128050 specifications

The Razor MX350, MX500, and MX650 are electric dirt bikes designed for young riders, providing a thrilling yet safe introduction to off-road biking. Each model offers distinct features while sharing a common DNA that ensures safety and ease of use.

The Razor MX350, model number 15128050, is particularly suited for younger riders with its manageable size and weight. It features a 24V (two 12V) sealed lead-acid rechargeable battery system that provides an impressive ride time of up to 40 minutes on a single charge. The MX350 supports a maximum rider weight of 140 pounds and can reach speeds of up to 14 miles per hour, making it perfect for neighborhood rides or light trails. The bike is equipped with a twist-grip throttle for smooth acceleration, and its high-torque motor offers a powerful experience. Additionally, the MX350 has a sturdy steel frame and 12-inch pneumatic knobby tires for enhanced stability and traction on various terrains.

Stepping up from the MX350, the Razor MX500 (model number 15128190) caters to slightly older and heavier riders. This model boasts a larger 36V battery system that allows for longer ride times of 40 minutes and speeds reaching up to 15 miles per hour. The MX500 is capable of supporting a maximum weight of 175 pounds. Its oversized, 16-inch front and 14-inch rear tires ensure superior grip and stability, while the dual suspension system significantly enhances comfort on bumpy surfaces. The electric motor provides a thrilling ride, offering exceptional power that encourages adventurous off-road experiences.

The Razor MX650 (model number 15165070) is the ultimate model in this trio, designed for riders up to 220 pounds. With its high-performance 36V battery system, the MX650 can hit speeds of 17 miles per hour and also delivers up to 40 minutes of continuous use. Its robust build includes larger 16-inch wheels that provide better ground clearance and superior handling on rough terrain. The bike is equipped with a rear suspension system that absorbs shocks effectively, making it suitable for more rugged trails. Like its counterparts, the MX650 features a quiet motor, which minimizes noise disturbances, allowing for enjoyable rides without compromising the environment.

All three models come with front and rear caliper brakes, ensuring effective stopping power for added safety. The sleek design and vibrant colors appeal to young riders, encouraging outdoor activity and promoting a fun, adventurous spirit. The Razor MX series combines innovative technology with durable construction, making these electric dirt bikes a great investment for parents looking to provide a safe and exhilarating riding experience for their children.
Top Page Image Contents