Razor MX350 15128050 Assembly and Set-Up, Charging the Battery, Attaching the Front Forks MX350

Page 4

Assembly and Set-Up

Charging the Battery

Your electric motorbike may not have a fully charged battery; therefore it is a good idea to charge the

battery prior to use.

 

 

 

 

 

 

 

• Initial charge time: 12 hours

• Run time: up to 40 minutes

• Recharge time: up to 8 hours,

• Average battery life: 250 charge/discharge cycles

depending on the level of depletion

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Charger

Port

Charger

 

Plug

2 Plug the charger plug into a

1 Plug the charger port into the

port on the electric motorbike.

wall outlet.

The charger works with the

 

power switch in either the on or

 

off position.

 

Attaching the Front Forks – MX350

WARNING:

Always disconnect your electric motorbike from the charger before cleaning with liquid.

Note: If your charger does not look like the one illustrated, your unit has been supplied with an alternative charger. The specifications and charging procedure would not change.

The charger has a small window with one LED or two LEDs to indicate the charge status. Refer to the illustration on the charger unit for the actual “charging” and “charged” status indications for your model charger.

Chargers have built-in over-charge protection to prevent battery from being over-charged.

Be sure to properly align the groove on the charger input

1Remove steering bolt, spacer sleeves, washers and nut from front fork assembly.

Loosen top fork crown bolts.

Top Fork Crown Bolt

Top Fork Crown with Pinch Clamps

Lower Fork Crown with Pinch Clamps

Fork

Spacer Sleeve

Washer

Nut

Steering Bolt

Washer

Spacer Sleeve

plug with the corresponding socket on the case; otherwise, no charging action will occur.

2Insert the spacer sleeves on the top and bottom of the frame.

3Slide the fork into position and insert the steering bolt. The bolt must go through the washer and spacer sleeve and between the steering bearings inside the frame.

4Install washer and nut onto steering bolt. Tighten until snug, then back off slightly to allow the steering to rotate freely with no binding or end-play. Tighten the top fork crown bolts.

3

WARNING:

Failing to properly adjust and tighten the nuts and bolts that affix the forks can cause you to lose control and fall.

Page 3 Page 5
Image 4
Page 3 Page 5
Contents Read and understand this entire manual before riding Contents Safety WarningsBefore You Begin Estimated Assembly and Set-Up TimeRequired Tools Charging the Battery Assembly and Set-UpAttaching the Front Forks MX350 Attaching the Handlebars Installing the Front Wheel MX500 / MX650Attaching the Front Fender and Number Plate Repair and Maintenance Testing the BrakesAdjusting the Brakes MX350 Inflating the TiresChain and Rear Tire Replacement MX350 Chain and Tire Replacement MX500 / MX650 Replacing the Fuse MX350 / MX500 / MX650 QChecking Spoke Tension MX500 / MX650Battery Care and Disposal Replacement Parts Repair CentersChain and Sprocket ChargerSB 1918 California Declaration Troubleshooting Guide Sometimes the vehicle Loose wires or connectors Vehicle does not stop Brakes are not adjusted properlyRepair Charger gets warm Normal response to charger useMX350 Parts MX350 Parts MX500 / MX650 Parts MX500 / MX650 Parts Safety reminders Warranty

MX500 15128190, MX650 15165070, MX350 15128050 specifications

The Razor MX350, MX500, and MX650 are electric dirt bikes designed for young riders, providing a thrilling yet safe introduction to off-road biking. Each model offers distinct features while sharing a common DNA that ensures safety and ease of use.

The Razor MX350, model number 15128050, is particularly suited for younger riders with its manageable size and weight. It features a 24V (two 12V) sealed lead-acid rechargeable battery system that provides an impressive ride time of up to 40 minutes on a single charge. The MX350 supports a maximum rider weight of 140 pounds and can reach speeds of up to 14 miles per hour, making it perfect for neighborhood rides or light trails. The bike is equipped with a twist-grip throttle for smooth acceleration, and its high-torque motor offers a powerful experience. Additionally, the MX350 has a sturdy steel frame and 12-inch pneumatic knobby tires for enhanced stability and traction on various terrains.

Stepping up from the MX350, the Razor MX500 (model number 15128190) caters to slightly older and heavier riders. This model boasts a larger 36V battery system that allows for longer ride times of 40 minutes and speeds reaching up to 15 miles per hour. The MX500 is capable of supporting a maximum weight of 175 pounds. Its oversized, 16-inch front and 14-inch rear tires ensure superior grip and stability, while the dual suspension system significantly enhances comfort on bumpy surfaces. The electric motor provides a thrilling ride, offering exceptional power that encourages adventurous off-road experiences.

The Razor MX650 (model number 15165070) is the ultimate model in this trio, designed for riders up to 220 pounds. With its high-performance 36V battery system, the MX650 can hit speeds of 17 miles per hour and also delivers up to 40 minutes of continuous use. Its robust build includes larger 16-inch wheels that provide better ground clearance and superior handling on rough terrain. The bike is equipped with a rear suspension system that absorbs shocks effectively, making it suitable for more rugged trails. Like its counterparts, the MX650 features a quiet motor, which minimizes noise disturbances, allowing for enjoyable rides without compromising the environment.

All three models come with front and rear caliper brakes, ensuring effective stopping power for added safety. The sleek design and vibrant colors appeal to young riders, encouraging outdoor activity and promoting a fun, adventurous spirit. The Razor MX series combines innovative technology with durable construction, making these electric dirt bikes a great investment for parents looking to provide a safe and exhilarating riding experience for their children.
Top Page Image Contents