Supra LAUNCH 22SSV, SUNSPORT 24V, SUNSPORT 22V, LAUNCH LTS Check Before running where applicable

Page 4

•Drain Plugs (Securely in place?)

•Life-Saving Devices (One for every person on board?)

•Steering System (Working smoothly and properly?)

•Fuel System (Adequate fuel? Leaks? Fumes?)

•Battery (Fully charged? Cable terminals clean and tight?)

•Engine (In Neutral?)

•Capacity Plate (Are you overloaded or overpowered?)

•Weather Conditions (Safe to go out?)

•Electrical Equipment (Lights, horn, pump, etc.?)

•Emergency Gear (Fire extinguisher, bailer, paddle, anchor & line, signaling device, tool kit, etc.?)

•Bilge Pump (Working properly?)

NOTE: Bilge pump should be checked prior to each use to ensure proper operation!

Check BEFORE running (where applicable)

•Engine Oil level

•Transmission Lubricant level

•Engine Drain Plug, Transom Drain Plug and Center Drain Plug

•Leakage (Fuel, water lines and connections)

DO NOT operate engine without cooling water flowing through water pump, otherwise pump will sustain damage and subsequent engine damage may result!

Check BEFORE running

•Oil Pressure: Refer to Engine Owner’s Manual

•Water Temperature: 160 degrees to 180 degrees for raw water systems (water is not recirculated), and 180 degrees to 200 degrees for closed cooling systems (water is recirculated).

•Idle RPM: (650-750) in gear.

•Maximum Forward RPM: See Engine Owner’s Manual.

•Shifting Linkage (Forward, Neutral and Reverse).

GASOLINE VAPORS CAN EXPLODE! It is very important to check for fuel spillage or leaks prior to each use of your boat.

•Check engine compartment for gasoline vapors.

•Operate blower for 4 minutes before starting the engine.

•Always operate blower below cruising speed.

NOTE: Please refer to your Engine Owner’s Manual for maximum RPM and engine break-in procedure.

SUPRA - 4

© 2005 Skier’s Choice, Inc.

Image 4

Contents Trademarks Table of Contents Boat InformationIntroduction IntroductionCheck Before running where applicable Important Safety Information Boating SafetySafety Training Organizations Safety EquipmentGeneral Safety Precautions Boaters must continuously be aware of weather conditionsSkiing Safety Carbon Monoxide CO SafetySki Pylon Extensions Product MisuseProper Seating Contact InformationSupra Basic Boating Rules Boating RulesEncountering Other Vessels Review and understand all local and state lawsSee examples of buoys and markers next Supra Supra Supra Comp LTS Sunsport Boat SpecificationsSupra Launch LTS Launch Launch 22SSV Launch 24SSV Operating Infomation Break In PeriodStarting & Operation Maximum Capacities Coast Guard RegulationsDo not exceed the maximum capacity of the boat Starting & Operation To Start Electronic Fuel Injection EFI EngineThrottle Lever Engine Warm-UpTransmission Lockout Bilge Area Center Drain Plug Rear Drain PlugFuel Precautions Filling the TankFueling Before FuelingInstrument Panel & Controls Speed CalibrationTemperature Gauge SpeedometerTachometer Engine HoursFuel Gauge Speedometer Paddle WheelVoltmeter Oil Pressure GaugeSetting Units Setting Deep AlarmSetting Shallow Alarm Depth SounderTroubleshooting Instrument does not Turn on TroubleshootingOut of Range Display Stereo Supra Supra Ignition Switch Blower Switch Horn SwitchSupra dealer Boat is in storageTilt Steering DC OutletDrive Warning Light Circuit Breaker PanelGravity Ballast System Priming the SystemSupra Ignition Keys Equipment & OptionsMirror Driver’s Seat & Seat Adjustment Inboard Motor BoxDrive Engine Compartment Never open the Motor Box while the boat is movingFlame Precautions Fire ExtinguisherDrive Ski Pylon Inboard Ski PylonStyle Rad-A-CageTo Raise Cage Pole Light Receptacle Pole LightTower Pole Light Courtesy LightsLifting Rings Ski PlatformBow Eye See Hoisting InstructionsSki Locker Detachable BracketBilge Inspection Plate Sundeck PropellerDouble-Up Seating Triple-Up SeatingTrim Switch & Gauge Hydraulic Wake PlateOptional Perfect Pass Glove BoxBattery Box Optional Boat HeaterWalk-Thru Windshield Optional Bimini TopSafety Lanyard/Engine Shut Off Switch CoolerWakeboard Racks Optional Tower SpeakersOptional Tonneau Cover Mooring CoverOptional Cockpit Cover Optional Walk-Through Curtain Optional Stereo AmpAir Inflator Do not leave air inflator running unattendedFuel Tank Drive Fuel TankFuel Vent While FuelingService & Maintenance Service & MaintenanceInboard Model Drive Model Cooling Systems Component LubricationEngine Oil and Filter Drive Remote Oil FilterOil Level Check Refer to Engine Manual for more informationTransmission Level Check Drive Fluid CheckChange Frequency Maintaining Fluid LevelInstallation & Precautions Shaft Log Packing NutSupra Cleaning, Care & Storage Fiberglass CareWashing Your Boat Rub Rail CareUpholstery Care Drying UpholsteryForeign Deposits Boat Hull ProtectionWinterization & Dry Storage WinterizationSummerization Hoisting Do not use the ski pylon to hoist the boatIdentification Number Technical InformationSupra Connecting the Trailer Trailer Plug Wire SchematicTrailering Your Boat Trailer & TowingProlong Trailer Life Trailer AlignmentInadvertent release of latch pin could result in injury Correct AlignmentUnloading Procedure Loading ProcedureBoat Buddy Surge Brakes Fluid ReservoirGold Series Oil Bath Bearings LoadingOptional Swing Tongue Supra Supra Limited Warranty Supra WarrantyOther Limitations Owner’s Responsibility Dealer’s ResponsibilitySupra Index Index