Char-Broil 463250511 manual Tank Screw at rear of cart

Page 22

15

Place cooking grates onto the firebox as shown.

Place the Warming Rack onto the the firebox. Make sure insert the Warming Rack ends into the holes properly as shown.

Warming Rack

Cooking rate

16	LP TANK IS SOLD SEPARATELY. Fill and leak check the tank before attaching to grill and regulator (see Use & Care section).
	Once tank has been filled and leak checked, place cylinder into cut-out in bottom shelf. Make sure tank valve is facing front of grill.

Secure tank with tank screw under bottom shelf. Insert regulator through large hole in right side panel.

See Use & Care section of this manual to perform the "Burner Flame Check" and for important safety instructions before using.

LP Tank valve must face to front of cart once tank is attached. Failure to install cylinder correctly may allow gas hose to be damaged in operation, resulting in the risk of fire.

Tank Valve
Facing Front.	Regulator	Tank Screw at rear of cart
	Regulator

LP Tank (not included)

Always keep LP tank in upright position during use, transport, and storage.

22

Image 22

Contents Estimated assembly time 30 minutes Date PurchasedINSTALLER/ASSEMBLER Installation Safety Precautions California PropositionUL listed Overfill Protection LP Liquefied Petroleum GasLP Cylinder Filling Only LP cylinders equipped with this type of valveUseDo not household cleaning agents. Damage to gas For your safetyLP Cylinder Leak Test Connection, do not use this regulator Leak Testing Valves, Hose and RegulatorTurn all grill control knobs to OFF For Safe Use of Your Grill and to Avoid Serious Injury Main Burner Ignitor LightingSideburner Match Lighting General Grill CleaningSideburner Ignitor Lighting Burner Flame CheckCleaning the Burner Assembly Storing Your GrillLimited Warranty Parts List Parts Diagram Assembly Grill head Regulator hose Upper back panel 5mm Flat Washer 5mm Lock Washer #10-24x3/8 Screw Left On fascia to attach bezel Sideburner Sideburner drip pan Burner tube Nut Right door Left door Tank Screw at rear of cart Burner Front Firebox Carryover Tube Hitch PinNatural Gas Bezel Screws Bezels Valve Stem Sideburner Grate Wingnut Orifice Orifice Removal Tool Valve80007894 Screws Bezel Valve Stem Natural Gas BezelValve Sideburner Outdoor Stove & Griddle Conversion Screws Bezel Valve Stem Natural Gas Bezel 80007886 Natural Gas Hose Conversion To the grill. Direction of gas flow is indicated on Connecting Your Grill to the Natural Gas SourceSocket Troubleshooting Emergencies Possible Cause Prevention/SolutionAUTO-CLEAN Troubleshooting Electronic Ignition SectionPage Warranty Registration Department Box Columbus, GA