Char-Broil 463240804 manual Very Important

Page 14

17

LP tank is sold separately. Fill and leak check the tank (see Use & Care section) before attaching to grill and regulator.

Once tank has been filled and leak checked, place tank into tank hole in bottom shelf. Make sure tank valve is facing front of grill. Secure tank with tank screw at rear of bottom shelf.

See Use & Care manual to perform the “Burner Flame

Check” and for important safety instructions before using.

CAUTION

Tank valve must face to front of cart once tank is attached.

Failure to install tank correctly may allow gas hose to be damaged in operation, resulting in the risk of fire.

Tank screw

Tank valve facing front.

18 VERY IMPORTANT!

Regulator and hose must pass UNDER hose bracket before connecting to LP tank. Read “Connecting Regulator to the LP Tank” in the Use and Care section of this manual.

Hose Bracket

Regulator and hose must pass UNDER hose bracket.

14 • 463240804

Image 14
Contents 463240804 80000327 Installation Safety Precautions Safety SymbolsTable of Contents Side Shelf Assembly 80000059 Description Grill Lid Assembly 80000301 Cart AssemblyGrill Bottom Assembly 80000308 KeyParts Diagram Model No Assembly Model No Align holes Regulator hose Fully tighten screws inside grill bottom at this time #10-24x3/8 screws AAA, 5mm lock washers BBB Valve clip Sideburner ignitor wire Pivot wire Smaller basket on left door, larger basket on right door Slide grease tray into back of grill Very Important AA Battery LP Tank Filling LP Tank Removal, Transport And StorageLP Liquefied Petroleum Gas LP Tank Exchange Connecting Regulator To The LP TankFor your safety LP Tank Leak TestLeak Testing Valves, Hose and Regulator Turn all grill control knobs to OFFIgnitor Lighting Safety TipsFor Safe Use Of Your Grill And To Avoid Serious Injury Ignitor Lighting The Sideburner General Grill CleaningMatch-Lighting Match LightingImmediately turn off gas at LP tank Cleaning The Burner AssemblyStoring Your Grill Wait for grill to coolIndirect Cooking Food SafetyHow To Tell If Meat Is Grilled Thoroughly Indirect Cooking InstructionsTroubleshooting Problem Possible Cause Prevention/SolutionTroubleshooting Electronic Ignition Problem Possible Cause Check Procedure Prevention/Solution463240804 Page 463240804 Division of W.C. Bradley Co. Columbus, GA