Char-Broil 463240804 manual #10-24x3/8 screws AAA, 5mm lock washers BBB

Page 9

7

Remove the two screws (M4x10mm) and washers (4mm) from the sideburner valve bracket.

Place sideburner valve under front of sideburner control panel so that valve stem comes through large hole. Place sideburner bezel over valve stem. Secure bezel to panel and valve using the two screws and washers you removed from the valve bracket. Press control knob onto valve stem.

Valve stem

Sideburner bezel

First, remove screws and washers from bracket.

Sideburner valve

8

Insert sideburner into shelf, placing end of burner over sideburner valve. Valve should be in center hole of burner tube. Make sure pin on bottom of burner is in center hole in shelf bracket. Secure burner to bracket with two

#10-24x3/8” screws (AAA), 5mm lock washers (BBB),

Sideburner

and 5mm flat washers (CCC). See illustration below for correct burner-to-valve engagement.

CCC

BBB

Pin

Correct

in hole

burner-to-valve

 

engagement

Valve should be in center hole in burner tube.

AAA

463240804 • 9

Image 9
Contents 463240804 80000327 Safety Symbols Installation Safety PrecautionsTable of Contents Grill Bottom Assembly 80000308 Description Grill Lid Assembly 80000301 Cart AssemblySide Shelf Assembly 80000059 KeyParts Diagram Model No Assembly Model No Align holes Regulator hose Fully tighten screws inside grill bottom at this time #10-24x3/8 screws AAA, 5mm lock washers BBB Valve clip Sideburner ignitor wire Pivot wire Smaller basket on left door, larger basket on right door Slide grease tray into back of grill Very Important AA Battery LP Tank Removal, Transport And Storage LP Liquefied Petroleum GasLP Tank Filling For your safety Connecting Regulator To The LP TankLP Tank Exchange LP Tank Leak TestTurn all grill control knobs to OFF Leak Testing Valves, Hose and RegulatorSafety Tips For Safe Use Of Your Grill And To Avoid Serious InjuryIgnitor Lighting Match-Lighting General Grill CleaningIgnitor Lighting The Sideburner Match LightingStoring Your Grill Cleaning The Burner AssemblyImmediately turn off gas at LP tank Wait for grill to coolHow To Tell If Meat Is Grilled Thoroughly Food SafetyIndirect Cooking Indirect Cooking InstructionsProblem Possible Cause Prevention/Solution TroubleshootingProblem Possible Cause Check Procedure Prevention/Solution Troubleshooting Electronic Ignition463240804 Page 463240804 Division of W.C. Bradley Co. Columbus, GA