Fire Magic REGAL II 82, 000 BTU Where to Install Your GAS Barbecue, Ventilation of Enclosures

Page 3

PLANNING FOR INSTALLATION OF YOUR REGAL II GOURMET SERIES BARBECUE

WHERE TO INSTALL

YOUR GAS BARBECUE

Fire Magic Gas Barbecues are designed for outdoor use only.

WARNING: Built-in models must be installed in masonry or other type of fireproof enclosure. The unit is not insulated and therefore must be installed with 18" of side and back clearance from unprotected combustible materials such as wood, plastic or stucco with wood framing.

With our Insulating Liner (Part #3175-50) you can safely install your Fire Magic Barbecue in wood cabinetry or other combustible enclosure.

For easy installation of your Fire Magic Barbecue a Masonry Installation Hanger (Part #3175-70 for black finish & 3175-80 for Stainless Steel) is available. It eliminates the requirement for any type of support structure under the Barbecue. This hanger can not be used in conjunction with the Insulating Liner above.

Do not install this unit under unprotected flammable surfaces. Do not install or use this appliance inside a building, garage, or any other enclosed area including recreational vehicles or boats.

This is a slide-in type unit designed to fit into open-front enclosures. The Front Panel (Face) of the unit is removable for gas hookup, servicing and Burner adjustment. The Face must therefore be removable after you install the unit.

INSTALLER NOTE: This unit should be installed so that it can be removed at a later date if factory service is required. Any protrusion into the Barbecue enclosure may obstruct the frame and prevent the unit from sliding into place (see "Gas Supply Plumbing Requirements", on page 4).

INSURING PROPER COMBUSTION AIR AND COOLING AIR FLOW

You must maintain proper air flow for your Fire Magic Barbecue to perform as it was designed (Figure 1). If airflow is blocked in any way, overheating and poor combustion will result. Make sure not to block the 1" front air inlet along the bottom of the Barbecue Face or the air vent openings along the outside-left and right edges of the Frame. Note: The 1" front air space also allows convenient access to the Drip Tray.

VENTILATION OF ENCLOSURES

When using Propane gas, take EXTREME CAUTION to ensure ample ventilation of gas vapor. Propane gas vapor is invisible and heavier than air. A DANGEROUS EXPLOSION could occur, resulting in SERIOUS INJURY OR LOSS OF LIFE, if Propane gas is allowed to accumulate and is then ignited.

Only one Propane gas cylinder may be located in an enclosure. Extra or spare cylinders must be stored outdoors out of the reach of children and outside of any building, garage or other enclosed area. READ AND

Figure 1 - Ventilation Diagram

FOLLOW ALL WARNINGS PROVIDED WITH PROPANE GAS CYLINDERS. Never locate a cylinder under or near the Barbecue unless sufficient ventilation and shielding is provided to prevent any heating of the cylinder, regulator and rubber hose.

Propane Cylinder Enclosures

To prevent invisible combustible gas from accumulating in the cylinder enclosure, you must provide adequate ventilation. This is accomplished by EITHER one side of the gas cylinder enclosure left completely open to the outside OR by providing four

(4)ventilation openings. Two openings are to be at the cylinder valve level (Approx. 16” above the floor) and at opposite walls of the enclosure. Two more openings must be at the floor level at opposite sides of the enclosure. The floor level openings must start at the floor and shall extend no higher than 5” above the floor. Each opening must have a minimum of 10 square inches (64.5 cm2) of free area. To achieve the proper ventilation, you may drill a series of holes, omit the grout from masonry joints or replace a brick with a hardware cloth screen. If the floor in the cabinet is raised and the space beneath the cabinet is open to the outside, the lower ventilation openings may be in the floor.

FOR YOUR SAFETY, you must provide these openings for drainage, replacement air and cross ventilation of any storage area exposed to possible leakage from gas connections, the Barbecue or Propane gas cylinder.

IMPORTANT: Additional requirements for safe use of Propane gas and gas cylinders appears on pg. 6 of this manual.

Household Propane Gas Service

Consult your gas supplier for ventilation requirements when connecting to a household Propane supply.

NOTE: Only Fire Magic Barbecue Models with the suffix -PA- in the model number are approved by C.S.A. for self contained Propane cylinders. Supplemental instructions are supplied with each self contained unit.

ELECTRICAL OUTLETS

Electrical outlets in the vicinity of the Barbecue, which might be used for Rotisserie motors or other appliances, must be properly grounded.

Installer and User Note: Keep electrical supply cords away from all heated surfaces.

3

Page 2 Page 4
Image 3
Page 2 Page 4
Contents Regal II Gourmet Series Outdoor GAS Barbecue 82,000 BTU Installation and Operating InstructionsInstructions for Fire Magic Regal II Gourmet Series GAS Barbecue Parts ListElectrical Outlets Where to Install Your GAS BarbecueInsuring Proper Combustion AIR and Cooling AIR Flow Ventilation of EnclosuresGAS Supply and Manifold Pressures Installing Your Fire Magic Regal II Gourmet Series BarbecueExhaust Removal GAS Supply Plumbing RequirementsAdjusting the Flame Height Adjusting Your BarbecueInstall the Flavor Grids AIR Shutter AdjustmentDrip Collection System Safety InformationBarbecue Safety and Maintenance USE and Care of Your BarbecueProtecting Parts and Finish Burner MaintenanceStainless Steel Cooking Grids Porcelain Coated Cast Iron GridsIf YOU Smell GAS Lighting InstructionsFor Automatic Lighting For Manual Lighting

000 BTU, REGAL II 82 specifications

The Fire Magic REGAL II 82,000 BTU is a high-performance gas grill designed for outdoor cooking enthusiasts who seek both power and elegance. This grilling machine seamlessly combines advanced technology, robust construction, and an array of features that elevate the outdoor cooking experience.

With an impressive 82,000 BTU output, the REGAL II delivers outstanding heat performance, enabling chefs to sear meats, grill vegetables, and prepare a variety of dishes with precision. The grill features a spacious cooking surface, accommodating multiple food items simultaneously, making it ideal for family gatherings or entertaining guests. This model also includes a stainless steel cooking grate that ensures excellent heat retention and distribution.

One of the standout features of the Fire Magic REGAL II is its advanced ignition system. The reliable push-button electronic ignition allows for quick and easy lighting, ensuring that users spend less time preparing and more time enjoying the grilling experience. Additionally, the grill is equipped with advanced burners made from high-quality stainless steel, which are designed to resist corrosion and provide even heat across the cooking surface.

The REGAL II also boasts a unique heat zone separator that allows users to maintain different cooking temperatures across the grill. This innovative feature permits a versatile cooking experience, letting you simultaneously grill different foods that require varying degrees of heat. In addition to this, the grill comes equipped with a built-in infrared rotisserie burner, perfect for slow-roasting meats to perfection.

Durability and aesthetics have been prioritized in the design of the Fire Magic REGAL II. The grill's construction features heavy-duty stainless steel, providing resilience against the elements while also imparting a sleek, modern look that complements any outdoor kitchen setup. The hood is designed with a double-walled construction to improve heat retention, and the commercial-grade cast aluminum body ensures long-lasting performance.

For added convenience, the REGAL II is equipped with built-in lights that illuminate the cooking surface at night, making it easy to keep an eye on your food regardless of the lighting conditions. The grill’s side shelves provide ample workspace for food prep, while storage options keep cooking tools and accessories organized and within reach.

In conclusion, the Fire Magic REGAL II 82,000 BTU gas grill stands out in the outdoor cooking market for its impressive performance, innovative features, and sturdy construction. Whether you are an amateur griller or a seasoned barbecue expert, this grill promises to enhance your outdoor cooking adventures with its blend of functionality and style.
Top Page Image Contents