Mcaution | Cuisinart CGG-180T manual

5.3 Installing the Gas Cylinder

(The propane gas cylinder is not provided with the appliance.)

A gas cylinder complying with the requirements listed in section 5.2 must be obtained before the grill can operate. Connect the LP cylinder to the grill outdoors only.

Read and follow all direction on the cylinder.

1.Turn the burner control knob to “OFF” position.

2.Remove the protective caps from the cylinder valve and coupling nut, if present.

3.Ensure grill legs are extended as shown in Assembly Instruction, Step 1 (page 6).

4.At rear of grill, push the cylinder into the threaded regulator connector and turn clockwise until tight.

5. TIGHTEN BY HAND ONLY. Do not use tools.

Removal Of The Gas Cylinder

1. Turn the burner control knob to “OFF” position.

2. Turn the cylinder counterclockwise until it comes off.

5.4 Checking for Gas Leak

mDANGER

Check gas system for leaks to prevent fire or explosion hazard

1.The “Leak Check” must be performed before lighting the grill and each time the cylinder is connected for use.

2.Do not smoke or allow other sources of ignition in the area while conducting a leak test.

3. Conduct the leak test outdoors in a well-ventilated area.

4. Do not use matches, lighters or a flame to check for leaks.

5. Do not use grill until all leaks have been stopped. If you are unable to stop a leak, disconnect the propane supply, and call for gas application service or your local propane gas supplier.

Leak Check Method

5.5 Lighting Instructions

1. Read all instructions before lighting.

2. Open lid during lighting.

3.Make sure the gas control knob is in “OFF” position.

4.Push the gas control knob and quickly turn counterclockwise to “HIGH” position. The igniter will click and light the burner.

5.If ignition does not occur in 5 seconds, turn the gas control knob off, wait

5 minutes, and repeat steps 2 - 5.* Before cooking on this grill for the first time, operate the grill for about 15 minutes with the lid closed and the gas turned on “HIGH”. This will “heat clean” the internal parts

and dissipate odor from the painted finish.

*Clean your grill after each use. See Section 6.3 for instructions

*If the burner does not light, turn the gas control knob off and wait 5 minutes to let the gas clear before you try again.

5.6 Match lighting

IMPORTANT!

A match lighting hole is located on the left side of the firebox.

Match lighting instructions:

1.Read all instructions before lighting.

2.Open lid during lighting.

3.Make sure the gas control knob is in “OFF” position.

4.Strike a long wooden match and position the burning match through the match lighting hole in the left side of the firebox. Place the flame near the bottom edge of the burner.

5.Push down and turn the burner control knob counterclockwise to the high setting.

6. The burner should light. The flame will carry around the burner. Allow grill to pre-heat with the grill lid closed for 2-3 minutes before cooking.

mCAUTION:

Do not touch any hot grill parts. The outside of the grill bottom especially becomes very hot during use. Use protective gloves to handle any parts that might become hot during use.

1.Make 2-3 oz. of leak solution by mixing one part liquid dishwashing soap with three parts water.

2.Make sure control knob is in the “OFF” position.

3.Spray or paint some leak solution on the cylinder and regulator connection.

4.Inspect the solution at the connections, looking for bubbles. If no bubbles appear, the connection is secure.

5.If bubbles appear, a leak is detected. Go to step 6.

6.Disconnect the cylinder from the regulator, and reconnect. Make sure the connection is secure and no leak is found before using the grill.

7.If you continue to see bubbles, DO NOT USE THE GRILL. Repeat the above process with a different LP cylinder. If leaks are still present, contact the customer service center.

5.7 Using the Grill

Inspect the burner flame by looking through the match lighting holes.

A good flame should be blue with some yellow tips coming from the burner holes. Yellow tips on flames up to 1/4“ in height are acceptable as long as no carbon or soot deposits appear.

During operation, stand to the side of grill when opening the grill lid.

Do not expose any part of your body directly above the cooking area.

The burner opening must be positioned properly over the valve orifices.

CGG-180T specifications

The Cuisinart CGG-180T is a portable tabletop grill that has gained popularity among outdoor cooking enthusiasts and casual grillers alike. Its compact design and powerful performance make it an ideal choice for picnics, tailgating, and small outdoor gatherings. This grill features a sleek stainless steel construction, offering both durability and a stylish appearance.

One of the standout features of the CGG-180T is its dual burners, which provide a combined output of 18,000 BTUs. This allows for quick heating and efficient cooking, ensuring that your food reaches the desired temperature in no time. The grill also incorporates a 285 square inch cooking surface, providing ample space for grilling everything from burgers and steaks to vegetables and skewers.

The cooking grates of the Cuisinart CGG-180T are made of enameled cast iron, which not only retains heat effectively but also provides excellent heat distribution for even cooking. The grates are designed to create perfect grill marks, adding a professional touch to your grilled dishes. Additionally, the grill is equipped with a built-in thermometer, allowing you to easily monitor the internal temperature of your food for perfect results.

Portability is a key aspect of the Cuisinart CGG-180T. With its lightweight design and folding legs, it can be easily transported to various outdoor events. The grill is also powered by a 20-pound propane tank, offering convenience and ease of use. The easy-to-use ignition system ensures that starting the grill is a hassle-free experience, enabling you to focus on enjoying your time with family and friends.

Safety features are integrated into the design of the CGG-180T, including a locking lid and sturdy legs that provide stability during use. This grill is also easy to clean, thanks to its removable grease tray, which collects drippings and makes post-cooking cleanup simple.

In summary, the Cuisinart CGG-180T portable tabletop grill stands out with its powerful dual burners, enameled cast iron cooking grates, easy ignition system, and portability. Whether you are grilling at home or on the go, it offers a blend of performance and convenience that caters to both novices and seasoned grillers. Its robust construction and thoughtful design make it a reliable companion for all your outdoor cooking adventures.