Weber Weber Liquid Propane Gas, 55057 04/10/00 manual Liquid Propane GAS Units only

Page 2

DANGER

Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property.

WARNINGS

Do not store a spare or disconnected liquid propane cylinder under or near this barbecue. Improper assembly may be dangerous. Please carefully follow the assembly instructions in

this manual.

After a period of storage, and/or nonuse, the Weber Gas Barbecue should be checked for gas leaks and burner obstructions before use. See instructions in this manual for correct procedures.

Do not operate the Weber gas barbecue if there is a gas leak present. Do not use a flame to check for gas leaks.

Combustible materials should never be within 24 inches of the top, bottom, back or sides of your Weber gas barbecue.

Do not put a barbecue cover or anything flammable on, or in the storage area under the barbecue.

Your Weber Gas Barbecue should never be used by children. Accessible parts of the barbecue may be very hot. Keep young children away while it is in use.

You should exercise reasonable care when operating your Weber gas barbecue. It will be hot during cooking or cleaning and should never be left unattended, or moved while in operation.

Should the burners go out while in operation, turn all gas valves off. Open the lid and wait five minutes before attempting to relight, using the lighting instructions.

Do not use charcoal or lava rock in your Weber gas barbecue.

Never lean over open grill or place hands or fingers on the front edge of the cooking box. Should a grease fire occur, turn off all burners and leave lid closed until fire is out.

Do not enlarge valve orifices or burner ports when cleaning the valves or burners. The Weber Gas Barbecue should be thoroughly cleaned on a regular basis.

Liquid propane gas is not natural gas. The conversion or attempted use of natural gas in a liquid propane unit or liquid propane gas in a natural gas unit is dangerous and will void your warranty.

Do not attempt to disconnect any gas fitting while your barbecue is in operation. Use heat-resistant barbecue mitts or gloves when operating barbecue.

LIQUID PROPANE GAS UNITS ONLY:

Use the regulator that is supplied with your Weber Gas Barbecue.

Do not attempt to disconnect the gas regulator or any gas fitting while your barbecue is in operation.

A dented or rusty liquid propane cylinder may be hazardous and should be checked by your liquid propane supplier. Do not use a liquid propane cylinder with a damaged valve.

Although your liquid propane cylinder may appear to be empty, gas may still be present, and the cylinder should be transported and stored accordingly.

If you see, smell or hear the hiss of escaping gas from the liquid propane cylinder:

1.Move away from liquid propane cylinder.

2.Do not attempt to correct the problem yourself.

3.Call your fire department.

A-2

Page 1 Page 3
Image 2
Page 1 Page 3
Contents Gas Grill Liquid Propane GAS Units only Warranty Customer Service Center South Hicks Road Palatine, ILContents Operating For Installation in CanadaStorage Genesis Silver-B LP Manifold, Hose and regulator assembled Page Page Page Assemble wheel frame Assemble frameContinue frame assembly Complete frame assemblyAdd cooking box assembly Insert castersYou will need manifold bracket Install manifold bracketInstall cylinder panel Install igniter Add fuel gaugeImportant LP Cylinder Information Fill liquid propane cylinderChecking the fuel level in your tank Check that all burner valves are offYou will need burner control knobs Every time you disconnect and reconnect a gas fitting Install the slide out bottom tray You will need lid, two hair pin cotters1 and two hinge pins2Install the right end trim piece with tool holders Right swing-up work surfaceView inside of control panel Shown, do not push the trim piece in all Install the left end trim piece and swing-up workSurface Way and do not add bolts yetYou will need work surface Install the work surfaceDo not use the work surface as a cutting board Install control panel and burner control knobs You will need Bottom shelf Install the thermometerYou will need Thermometer Lighting To ExtinguishOFF the cylinder and burner control Manual LightingStill flowing to the burners. After turning Knobs, wait at least 5 minutes for the gasStorage and/or Nonuse CleaningCooking Refilling the Liquid Pro Pane CylinderRegulator coupling and could cause a leak Connection. Using a wrench could damageTo Connect the hose to the cylinder Liquid Propane CylinderInders Safe handling tips forLiquid Propane Gas Cyl Liquid Propane LP CylindersSpider Stopper Guards Annual MaintenanceInspection and Cleaning of the Weber Water, may be slightly corrosive, all connectionsMain Burner Flame Pattern General MaintenanceMain Burner Cleaning Procedure Weber Spider Stopper GuardsReplacing Main Burners Positioned properly over the valve orifices2Crossover Ignition System Operations Burners burn with a yellow or Barbecue temperature onlyFlame is low when burner is on Orange flame, in conjunction with

55057 04/10/00, Weber Liquid Propane Gas specifications

Weber Weber Liquid Propane Gas Model 55057 is an exceptional outdoor cooking appliance designed for grilling enthusiasts who appreciate efficiency, quality, and versatility. Launched on April 10, 2000, this grill continues to impress with its robust construction and user-friendly features.

One of the standout characteristics of the Weber 55057 is its durable build quality, featuring a porcelain-enameled lid and bowl that ensures long-lasting performance while delivering superior heat retention. The stainless steel burners are built to endure high temperatures, allowing for even cooking across the grilling surface. These burners provide a total of 30,000 BTUs of heating power, making it easy to achieve the desired sear or cook a variety of foods to perfection.

The grill's 3-burner system enables versatile cooking options, allowing users to create different grilling zones for optimal food preparation. This technology provides the ability to cook items at different temperatures simultaneously, an essential feature for achieving the best results with various types of food, from meats to vegetables.

The 55057 is equipped with an expansive grilling area that spans 508 square inches, providing ample space to cook multiple meals at once. Additionally, the grill includes a warming rack, giving users the flexibility to keep cooked items warm without overcooking them.

Another notable feature is the electronic ignition system that provides reliable startups with the push of a button, eliminating the hassle associated with manual start methods. It also features heavy-duty casters for easy mobility, ensuring that you can effortlessly move it around your outdoor space as needed.

Moreover, the Weber 55057 is designed with easy-to-clean grease management systems, making maintenance a breeze. This attention to cleanliness ensures a safer grilling environment and prolongs the life of the appliance.

In summary, the Weber Weber Liquid Propane Gas Model 55057 is an industry-leading grill known for its durability, cooking efficiency, and user-centric design. With innovative technologies like a powerful burner system, ample cooking space, and convenient features, this grill is a perfect choice for both novice cooks and seasoned grill masters seeking a reliable outdoor cooking experience. The model’s lasting appeal and high performance make it a cherished addition to any outdoor kitchen setup.
Top Page Image Contents