Weber Weber Liquid Propane Gas Burners burn with a yellow or, Orange flame, in conjunction with

Page 36

Troubleshooting

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Problem

Check

Cure

 

 

 

 

 

 

 

 

 

 

 

 

 

Burners burn with a yellow or

Inspect Weber Spider Stopper

Clean Weber Spider Stopper

 

 

 

 

 

 

 

orange flame, in conjunction with

Guards for possible obstructions.

Guards. (See Section “Annual

 

 

 

 

 

 

 

the smell of gas.

(Blockage of holes.)

Maintenance”)

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Burners do not light. -or- Burners

The excess flow satety device,

To reset the excess flow safety

 

 

 

 

 

 

 

have a small flickering flame in

which is part of the barbecue to

device turn all burner control knobs

 

 

 

 

 

 

 

the HIGH position. -or-

cylinder connection, may have

and the cylinder valve OFF.

 

Barbecue temperature only

activated.

Disconnect the regulator from the

 

 

 

 

 

 

 

reaches 250˚ to 300˚ in the HIGH

 

cylinder. Turn burner control knobs to

 

position.

 

HIGH. Wait at least 1 minute. Turn

 

 

 

burner control knobs OFF. Reconnect

 

 

 

the regulator to the cylinder. Turn

 

 

 

cylinder valve on slowly. Refer to

 

 

 

“Lighting Instructions”.

 

 

 

 

 

 

 

Burner does not light, or flame is

Is LP fuel low or empty?

Refill LP cylinder.

 

low in HIGH position.

 

 

 

 

 

Is fuel hose bent or kinked?

Straighten fuel hose.

 

 

 

 

 

 

 

 

 

Does the Front burner light with a

If you can light the Front burner with

 

 

match?

a match, then check the Crossover

 

 

 

Ignition System.

 

 

 

 

 

 

 

Experiencing flare-ups:

Are you preheating barbecue in the

All burners on high for 10 to 15

 

 

prescribed manner?

minutes for preheating.

 

 

 

 

 

 

 

Are the cooking grates and

Clean thoroughly. (See Section

 

 

Flavorizer bars heavily coated with

“Cleaning”)

 

 

burned-on grease?

 

 

 

 

m CAUTION: Do not line the

 

 

 

 

 

 

 

 

 

 

bottom tray with aluminum foil.

Is the bottom tray “dirty” and not

Clean bottom tray

 

 

allowing grease to flow into catch

 

 

 

 

 

pan?

 

 

 

 

 

 

 

 

 

Burner flame pattern is erratic.

Are burners clean?

Clean burners. (See Section

 

Flame is low when burner is on

 

“General Maintenance”.)

 

HIGH. Flames do not run the

 

 

 

 

 

whole length of the burner tube.

 

 

 

 

 

 

 

 

 

 

Inside of lid appears to be

The lid is porcelain-on-steel, not

Clean thoroughly. (See Section

 

“peeling.” (Resembles paint

paint. It cannot “peel”. What you are

“Cleaning”.)

 

peeling.)

seeing is baked on grease that has

 

 

 

 

 

turned to carbon and is flaking off.

 

 

 

 

 

THIS IS NOT A DEFECT.

 

 

 

 

 

 

 

 

 

If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your region using the contact information sheet provided with your manual.

Page 35 Page 36
Image 36
Page 35 Page 36
Contents Gas Grill Liquid Propane GAS Units only Warranty Customer Service Center South Hicks Road Palatine, ILContents For Installation in Canada StorageOperating Genesis Silver-B LP Manifold, Hose and regulator assembled Page Page Page Assemble wheel frame Assemble frameContinue frame assembly Complete frame assemblyAdd cooking box assembly Insert castersInstall manifold bracket Install cylinder panelYou will need manifold bracket Install igniter Add fuel gaugeImportant LP Cylinder Information Fill liquid propane cylinderCheck that all burner valves are off You will need burner control knobsChecking the fuel level in your tank Every time you disconnect and reconnect a gas fitting Install the slide out bottom tray You will need lid, two hair pin cotters1 and two hinge pins2Install the right end trim piece with tool holders Right swing-up work surfaceView inside of control panel Install the left end trim piece and swing-up work SurfaceShown, do not push the trim piece in all Way and do not add bolts yetInstall the work surface Do not use the work surface as a cutting boardYou will need work surface Install control panel and burner control knobs Install the thermometer You will need ThermometerYou will need Bottom shelf Lighting To ExtinguishManual Lighting Still flowing to the burners. After turningOFF the cylinder and burner control Knobs, wait at least 5 minutes for the gasCleaning CookingStorage and/or Nonuse Refilling the Liquid Pro Pane CylinderConnection. Using a wrench could damage To Connect the hose to the cylinderRegulator coupling and could cause a leak Liquid Propane CylinderSafe handling tips for Liquid Propane Gas CylInders Liquid Propane LP CylindersAnnual Maintenance Inspection and Cleaning of the WeberSpider Stopper Guards Water, may be slightly corrosive, all connectionsGeneral Maintenance Main Burner Cleaning ProcedureMain Burner Flame Pattern Weber Spider Stopper GuardsReplacing Main Burners Positioned properly over the valve orifices2Crossover Ignition System Operations Barbecue temperature only Flame is low when burner is onBurners burn with a yellow or Orange flame, in conjunction with

55057 04/10/00, Weber Liquid Propane Gas specifications

Weber Weber Liquid Propane Gas Model 55057 is an exceptional outdoor cooking appliance designed for grilling enthusiasts who appreciate efficiency, quality, and versatility. Launched on April 10, 2000, this grill continues to impress with its robust construction and user-friendly features.

One of the standout characteristics of the Weber 55057 is its durable build quality, featuring a porcelain-enameled lid and bowl that ensures long-lasting performance while delivering superior heat retention. The stainless steel burners are built to endure high temperatures, allowing for even cooking across the grilling surface. These burners provide a total of 30,000 BTUs of heating power, making it easy to achieve the desired sear or cook a variety of foods to perfection.

The grill's 3-burner system enables versatile cooking options, allowing users to create different grilling zones for optimal food preparation. This technology provides the ability to cook items at different temperatures simultaneously, an essential feature for achieving the best results with various types of food, from meats to vegetables.

The 55057 is equipped with an expansive grilling area that spans 508 square inches, providing ample space to cook multiple meals at once. Additionally, the grill includes a warming rack, giving users the flexibility to keep cooked items warm without overcooking them.

Another notable feature is the electronic ignition system that provides reliable startups with the push of a button, eliminating the hassle associated with manual start methods. It also features heavy-duty casters for easy mobility, ensuring that you can effortlessly move it around your outdoor space as needed.

Moreover, the Weber 55057 is designed with easy-to-clean grease management systems, making maintenance a breeze. This attention to cleanliness ensures a safer grilling environment and prolongs the life of the appliance.

In summary, the Weber Weber Liquid Propane Gas Model 55057 is an industry-leading grill known for its durability, cooking efficiency, and user-centric design. With innovative technologies like a powerful burner system, ample cooking space, and convenient features, this grill is a perfect choice for both novice cooks and seasoned grill masters seeking a reliable outdoor cooking experience. The model’s lasting appeal and high performance make it a cherished addition to any outdoor kitchen setup.
Top Page Image Contents