Weber 41995 manual Lighting the Smoker Burner

Operating Instructions

Lighting the Smoker Burner 1

WARNING: Check hose before each use of grill for
nicks, cracking, abrasions or cuts. If the hose is		2,3,9
found to be damaged in any way, do not use the
grill. Replace using only Weber® authorized
replacement hose Contact the Customer Service
Representative in your region using the contact
information sheet provided with your manual.	6	8
1) Open the grill lid.

DANGER:
Failure to open the lid while igniting the grill, or not	4
waiting 5 minutes to allow the gas to clear if the grill
does not light, may result in an explosive flare-up	7	5
which can cause serious bodily injury or death.
2) Open smoker box lid	4
3) Fill smoker with water soaked wood chunks or chips.	*The grill illustrated may have slight differences than the
4) Make sure all burner control knobs are turned OFF.
	model purchased.
(Push control knob down and turn clockwise to ensure
that it is in the OFF position.)
WARNING: The burner control knobs must be in the	5) Turn the cylinder on by turning the cylinder valve
OFF position before turning on the liquid propane
	counterclockwise.
cylinder tank valve. If they are not in the OFF position,
	WARNING: Do not lean over the open grill while
when you turn on the LP cylinder valve, the “excess
	lighting.
gas flow control” feature will activate, limiting the flow
	6) Push smoker burner control knob down and turn to
of gas from the LP cylinder. If this should occur, turn
	START/HI.
OFF the LP cylinder valve and burner control knobs.
	7) Push and hold down the Igniter button until burner
Then start over.
	ignites. You will hear the igniter sparking.
DANGER:	8) Check that the burner is lit by looking through the
When the “excess gas flow control” feature is	cooking grate.
activated, a small amount of gas is still flowing to the	DANGER:
burners. After turning OFF the cylinder and burner
	If the smoker burner does not light, turn the burner
control knobs, wait at least 5 minutes for the gas to
	control knob to OFF and wait 5 minutes to let the gas
clear before attempting to light the grill. Failure to do
	clear before you try again or try to light with a match.
so may result in an explosive flare-up, which can
cause serious bodily injury or death.	9) Close smoker cover after wood starts to smolder and
	turn control knob to LOW.

1
2,3,9	To Extinguish
	Push down and turn each burner control knob clockwise
	to OFF position. Turn gas supply OFF at the source.
6	8

4
7	5
	4

D-7