Pride Mobility Traveller Plus HD manual Battery Pack, See figure, Tiller Console Fuse

Page 19

BATTERY PACK FUSE

Figure 7. Battery Pack

Figure 8. 3-Amp Tiller Console Fuse

I I I . Y O U R T R A V E L S C O O T E R

Motor/Transaxle Assembly

The motor/transaxle assembly is an electromechani- cal unit that converts electrical energy from your Travel Scooter’s batteries into the controlled mechanical en- ergy that drives the Travel Scooter’s wheels.

BATTERY PACK

Your Travel Scooter is equipped with an innovative, easy to remove battery pack. A handle on the top of the battery pack makes it easy to lift the pack off of the Travel Scooter with one hand. The battery pack contains two batteries, the charger port, the main cir- cuit breaker (reset button), and the battery pack fuse.

See figure 7.

Charger Port

The 3-pin end of the charger power cord plugs into this port.

MAIN CIRCUIT BREAKER	BATTERY PACK HANDLE
(RESET BUTTON)

CHARGER PORT

BATTERY

PACK

Main Circuit Breaker (Reset Button)

When the voltage in your Travel Scooter’s batteries becomes low or the Travel Scooter is heavily strained because of excessive loads or steep inclines, the main circuit breaker may trip to protect the motor and elec- tronics from damage.

! The main circuit breaker reset button pops out when the breaker trips.

!When the breaker trips, the entire electrical sys- tem of your Travel Scooter shuts down.

!Allow a minute or two for your Travel Scooter’s

electronics to “rest.”

!Push in the reset button to reset the main circuit breaker.

!If the main circuit breaker trips frequently, you may need to charge your batteries more often. You may also need to have your authorized Pride Provider perform a load test on your Travel Scooter’s batteries.

!If the main circuit breaker trips repeatedly, see your authorized Pride Provider for service.

TILLER CONSOLE FUSE

The fuse located under the battery pack protects the tiller console electronics. See figure 8. In the event any component of the tiller console is not responding, check this fuse. See VIII. “Basic Troubleshooting” for fuse replacement instructions.

Elite Traveller Plus/Plus HD

www.pridemobility.com

19

Image 19

Contents Elite Traveller Plus F E T Y G U I D E L I N E S III N T E N T SShipping and Delivery SafetyN T R O D U C T I O N PURCHASER’S AgreementS a F E T Y Product Safety SymbolsS a F E T Y S a F E T Y General Removable Parts PRE-RIDE Safety CheckModifications Tire Inflation Weight LimitationsIncline Information Maximum Recommended Incline Angle Braking Information Cornering InformationCorrect Curb Approach Outdoor Driving SurfacesDoors Inclement Weather PrecautionsFreewheel Mode Stairs and EscalatorsMotor Vehicle Transport ElevatorsLIFT/ELEVATION Products BatteriesPositioning Belts Reaching and BendingALCOHOL/SMOKING Prescription DRUGS/PHYSICAL LimitationsElectromagnetic and Radio Frequency Interference EMI/RFI To Move Backward, use either of the following I . Y O U R T R a V E L S C O O T E RTiller Console To Move Forward, use either of the followingRear Section Horn ButtonSee figure Battery PackTiller Console Fuse See figures 10, 11, To reinstall the shroud pieces, placeShroud Panels To remove the shroud panel piecesB a T T E R I E S a N D C H a R G I N G Reading Your Battery VoltageCharging Your Batteries What if my Travel Scooter’s batteries will not charge? Frequently Asked QuestionsFollow these easy steps to charge your batteries safely How does the charger work?How can I get maximum range or distance per charge? How can I ensure maximum battery life?Can I use a different charger? How often must I charge the batteries?How do I change a battery in my Travel Scooter? What type and size of battery should I use?What about public transport? Why do my new batteries seem weak?Getting Onto Your Travel Scooter PRE-RIDE Adjustments and ChecksP E R a T I O N Before Getting Onto Your Travel ScooterGetting OFF of Your Travel Scooter Power Down Timer FeatureC O M F O R T a D J U S T M E N T S Tiller Angle AdjustmentSeat Rotation Adjustment Armrest Width AdjustmentFront Storage Area Seat Height AdjustmentI . D I S a S S E M B L Y a N D a S S E M B L Y DisassemblyFrame Separation AssemblyDiagnostic Beep Codes I I . B a S I C TroubleshootingWhat if the main circuit breaker repeatedly trips? What if the Travel Scooter’s batteries won’t charge?C a R E a N D M a I N T E N a N C E Motor Brushes Axle Bearings and the MOTOR/TRANSAXLE AssemblyNylon Lock NUT Replacement ABS Plastic ShroudsA R R a N T Y Exclusions also include components with damage caused by P E N D I X I Specification S Travel Scooter Dimensions T E S T E S T E S INFMANU3231