Invacare TDX 3 SE, TDX 5, TDX 4 manual Batteries

Page 51

SECTION 7—BATTERIES

SECTION 7—BATTERIES

WARNING

After ANY adjustments, repair or service and before use, make sure all attaching hardware is tightened securely - otherwise injury or damage may occur.

Warnings for Handling and Replacing Batteries

WARNING

Make sure power to the wheelchair is Off before performing these procedures.

The use of rubber gloves is recommended when working with batteries.

Invacare strongly recommends that battery installation and battery replacement ALWAYS be done by a qualified technician.

After ANY adjustments, repair or service and before use, make sure all attaching hardware is tightened securely - otherwise injury or damage may result.

22NF batteries weigh 37 pounds each. GP24 batteries weigh 51 pounds each. Use proper lifting techniques (lift with your legs) to avoid injury.

Use MK p/n M24SLDG or p/n M22NFSLDG batteries only. Failure to use the correct battery size and/or voltage may cause damage to your wheelchair and give you unsatisfactory performance.

ALWAYS use a battery lifting strap when lifting a battery. It is the most convenient method and assures that the battery acid will not spill. It also helps to prolong the life of the battery.

DO NOT tip the batteries. Keep the batteries in an upright position.

NEVER allow any of your tools and/or battery cable(s) to contact both battery post(s) at the same time. An electrical short may occur and serious personal injury or damage may occur.

When tightening the clamps, ALWAYS use a box wrench. Pliers will “round off” the nuts. NEVER wiggle the battery terminal(s)/post(s) when tightening. The battery may become damaged.

The POSITIVE (+) RED battery cable MUST connect to the POSITIVE (+) battery terminal(s)/post(s), otherwise serious damage will occur to the electrical system.

Install protective caps on POSITIVE (+) and NEGATIVE (-) battery terminals.

DO NOT remove fuse or mounting hardware from POSITIVE (+) RED battery cable mounting screw.

NOTE: If there is battery acid in the bottom of the battery tray or on the sides of the battery(ies), apply baking soda to these areas to neutralize the battery acid. Before reinstalling the existing or new battery(ies), clean the baking soda from the battery tray or battery(ies) being sure to avoid contact with skin and eyes. Determine source of contamination. Never install/reinstall a battery with a cracked or otherwise damaged case.

Part No 1143150

51

TDX™ Wheelchairs

Page 50 Page 52
Image 51
Page 50 Page 52
Contents TDX Wheelchairs Reference Documents Reference DocumentsManual Part Number Table of Contents Register Your Product Product Registration Form Fold here Cut Along Line Special Notes Signal Word MeaningTrro and Trbkts Warnings All Wheelchairs Label LocationsDrive Push Wheelchairs without Trro Wheelchairs with Trro Typical Product Parameters Adult JuniorWidth Adult Adjustable WidthWeight Without 22NF Batteries TDX 3 SE General Guidelines Repair or Service InformationOperation Information Wheelchairs with Trro or Trbkts Only Tire PressureCharging Batteries ElectricalBatteries Grounding InstructionsWeight Training Weight LimitationRain Test Stability and Balance SAFETY/HANDLING of WheelchairsCoping with Everyday Obstacles Reaching, Leaning and Bending Forward Pinch Points Reaching, Bending BackwardStairways Transferring To and From Other Seats Transferring To and From Other SeatsEMI Information EMI InformationEMI Information Safety INSPECTION/ Troubleshooting Safety Inspection ChecklistsInspect/Adjust Initially Inspect/Adjust Weekly Inspect/Adjust MonthlyInspect/Adjust Periodically Troubleshooting Mechanical Inspect/Adjust Every 18 MonthsSolutions Troubleshooting Electrical SPJ+, SPJ+ w/PSS or SPJ+ w/ACC JoysticksDisplay Description Definition Number Error Code Possible Solution Symptom Probable Cause SolutionsMPJ+, PSR+, PSF+ Joysticks or Displays BAD Joystick CAL Values DON’T Checking Battery Charge LevelJoystick Action Turning the Power On/OffWheelchair Operation Operating the WheelchairMovement Action Using the Joystick to Drive the WheelchairSpeedometer On/Off ButtonCharger/Programming Input Service IndicatorSpeed Control Buttons JoystickInformation Gauge Display MPJ+ Joystick Switches and Indicators Drive Select Toggle SwitchSpeed Control LCD Display Screens LCD Display ECU Programmable Mono Port 1/2 or External Mode Switch Remote On/Off SwitchWheelchair Operation Icon Description Mode Switch Preparing the Joystick for UseMemory Card Slot Repositioning the Joystick Tilting the Seat Assembly Tilting the Seat Assembly BackSeat Tilting the Seat Assembly Tilting the Seat Assembly ForwardBatteries Positive Using the Proper BatteriesRemoving the Battery Door and Rear Shrouds Removing/Installing the Batteries From/Into the WheelchairTrbkts Removing the Batteries Bracket Step Battery Door StepRemoving the Batteries Installing Batteries Installing BatteriesReplacing Batteries Installing the Battery Door and Rear ShroudBatteries RED Immediately Cleaning Battery TerminalsMPJ+ Joystick When to Charge BatteriesCharging Batteries SPJ+ JoysticksCharging Batteries Description and Use of Battery ChargersCharging Batteries Tool Quantity CommentsGearless Brushless GBMotors Motor LOCKS/FORKSDisengaging/Engaging Motor Lock Levers Standard and Heavy Duty 4 Pole MotorsAdjusting Forks Adjusting ForksTransport Ready Package Trro Compliance Information About Transport Ready PackagesPositioning the Wheelchair in the Vehicle SpecificationsModel Motor Wheelchair Weight Limit Adult Junior Securing the Wheelchair to the VehicleSecuring the Wheelchair Securement PointsWheelchair-Anchored Belts Securing the OccupantWheelchair-Anchored Belts Vehicle-Anchored Belts Seating SystemRating Description Positioning Belts Positioning BeltsGlobal Limited Warranty Excluding Canada Global Limited Warranty Excluding CanadaUSA Canada Limited Warranty

TDX 5, TDX 3, TDX 3 SE, TDX 4 specifications

Invacare has established itself as a leading manufacturer of mobility solutions, and its TDX series of power wheelchairs exemplifies the company's commitment to innovation, comfort, and user-centric design. The TDX 4, TDX 3 SE, TDX 3, and TDX 5 are prominent models within this series, each equipped with cutting-edge features and technologies that cater to the diverse needs of users.

The TDX 4 is designed for superior maneuverability and driving performance. It boasts a unique Mid-Wheel Drive technology, which ensures that the chair can pivot in place with ease, allowing users to navigate tight spaces effortlessly. The TDX 4 is equipped with a highly adjustable seating system and a modular design that allows for customization based on user preferences and needs. With an active anti-tip system, the TDX 4 ensures stability on slopes and uneven terrains, enhancing user safety.

Next in the lineup is the TDX 3 SE, which emphasizes enhanced seating and suspension systems. Users can enjoy a smooth ride thanks to its advanced suspension that absorbs shocks and vibrations. The TDX 3 SE offers flexible seating options, including tilt, recline, and elevating legrests, allowing for optimal positioning and comfort. With a robust driving range, the TDX 3 SE is perfect for individuals looking to explore their surroundings while ensuring adequate support and comfort.

The TDX 3, another noteworthy entry, incorporates many of the features found in its siblings but is tailored for those who need a more straightforward approach. This model is lightweight yet durable, making it easy to transport and manage. With a focus on reliability and ease of use, the TDX 3 is an excellent choice for individuals who prioritize practicality without compromising on quality.

Finally, the TDX 5 stands out with its advanced technological integration. It features smart technology that allows for intuitive control and customization. The control systems are designed to be user-friendly, accommodating those with varying levels of dexterity. Advanced battery technology ensures long-lasting performance, while the ergonomic design promotes comfort during extended use.

In conclusion, the Invacare TDX series—including the TDX 4, TDX 3 SE, TDX 3, and TDX 5—offers a range of features that cater to different mobility needs. With their focus on maneuverability, comfort, and technological innovation, these power wheelchairs empower users to regain independence and enjoy a more active lifestyle.
Top Page Image Contents