Invacare TDX 5, TDX 3 SE, TDX 4 manual Removing/Installing the Batteries From/Into the Wheelchair

Page 53

SECTION 7—BATTERIES

Removing/Installing the Batteries From/Into the Wheelchair

Removing the Battery Door and Rear Shrouds

CAUTION

Place the wheelchair in a well ventilated area where work can be performed with- out risking damage to carpeting or floor covering.

NOTE: For this procedure, refer to FIGURE 7.1 on page 54 and FIGURE 7.2 on page 55.

1.Verify the joystick On/Off switch is in the Off position.

2.Remove the two thumb screws that secure the rear shroud to the wheelchair.

3.Remove the rear shroud from the wheelchair.

4.TRRO and TRBKTS Options Only - Perform the following steps:

A.Remove two thumb screws that secure the top controller shroud (FIGURE 7.2) to the battery box.

B.Remove the top controller shroud from the battery box.

5.Formula PTO Plus ONLY - Tilt the PTO Plus back. Refer to Tilting the Seat Assembly on page 49.

6.Remove both mounting screws from side of battery door.

7.Remove the battery door from the front of wheelchair.

8.TRRO and TRBKTS Options Only - Perform the following steps (FIGURE 7.2):

A.Remove the four screws and four locknuts (if applicable) that secure the battery support bracket to the battery box.

B.Remove the battery support bracket.

9.Disconnect the controller from the batteries at the rear of the wheelchair.

10.Remove the batteries. Proceed to one of the following procedures:

• Wheelchairs without Elevate - Removing the Batteries on page 55.

• Wheelchairs with Elevate - Removing/Installing the Batteries From/Into the Wheelchair on page 53.

Part No 1143150

53

TDX™ Wheelchairs

Page 52 Page 54
Image 53
Page 52 Page 54
Contents TDX Wheelchairs Manual Part Number Reference DocumentsReference Documents Table of Contents Register Your Product Product Registration Form Fold here Cut Along Line Special Notes Signal Word MeaningTrro and Trbkts Warnings All Wheelchairs Label LocationsDrive Push Wheelchairs without Trro Wheelchairs with Trro Width Typical Product ParametersAdult Junior Adult Adjustable WidthWeight Without 22NF Batteries TDX 3 SE General Guidelines Repair or Service InformationOperation Information Wheelchairs with Trro or Trbkts Only Tire PressureBatteries ElectricalGrounding Instructions Charging BatteriesRain Test Weight TrainingWeight Limitation Stability and Balance SAFETY/HANDLING of WheelchairsCoping with Everyday Obstacles Reaching, Leaning and Bending Forward Pinch Points Reaching, Bending BackwardStairways Transferring To and From Other Seats Transferring To and From Other SeatsEMI Information EMI InformationEMI Information Inspect/Adjust Initially Safety INSPECTION/ TroubleshootingSafety Inspection Checklists Inspect/Adjust Periodically Inspect/Adjust WeeklyInspect/Adjust Monthly Solutions Troubleshooting MechanicalInspect/Adjust Every 18 Months Display Description Definition Troubleshooting ElectricalSPJ+, SPJ+ w/PSS or SPJ+ w/ACC Joysticks MPJ+, PSR+, PSF+ Joysticks or Displays Number Error Code Possible SolutionSymptom Probable Cause Solutions BAD Joystick CAL Values DON’T Checking Battery Charge LevelWheelchair Operation Turning the Power On/OffOperating the Wheelchair Joystick ActionMovement Action Using the Joystick to Drive the WheelchairSpeedometer On/Off ButtonSpeed Control Buttons Service IndicatorJoystick Charger/Programming InputInformation Gauge Display Speed Control MPJ+ Joystick Switches and IndicatorsDrive Select Toggle Switch LCD Display Screens LCD Display ECU Wheelchair Operation Icon Description Programmable Mono Port 1/2 or External Mode SwitchRemote On/Off Switch Memory Card Slot Mode SwitchPreparing the Joystick for Use Repositioning the Joystick Seat Tilting the Seat AssemblyTilting the Seat Assembly Back Tilting the Seat Assembly Tilting the Seat Assembly ForwardBatteries Positive Using the Proper BatteriesRemoving the Battery Door and Rear Shrouds Removing/Installing the Batteries From/Into the WheelchairTrbkts Removing the Batteries Bracket Step Battery Door StepRemoving the Batteries Installing Batteries Installing BatteriesReplacing Batteries Installing the Battery Door and Rear ShroudBatteries RED Immediately Cleaning Battery TerminalsCharging Batteries When to Charge BatteriesSPJ+ Joysticks MPJ+ JoystickCharging Batteries Description and Use of Battery ChargersCharging Batteries Tool Quantity CommentsDisengaging/Engaging Motor Lock Levers Motor LOCKS/FORKSStandard and Heavy Duty 4 Pole Motors Gearless Brushless GBMotorsAdjusting Forks Adjusting ForksTransport Ready Package Trro Compliance Information About Transport Ready PackagesModel Motor Wheelchair Weight Limit Adult Junior SpecificationsSecuring the Wheelchair to the Vehicle Positioning the Wheelchair in the VehicleSecuring the Wheelchair Securement PointsWheelchair-Anchored Belts Securing the OccupantWheelchair-Anchored Belts Rating Description Vehicle-Anchored BeltsSeating System Positioning Belts Positioning BeltsGlobal Limited Warranty Excluding Canada Global Limited Warranty Excluding CanadaUSA Canada Limited Warranty

TDX 5, TDX 3, TDX 3 SE, TDX 4 specifications

Invacare has established itself as a leading manufacturer of mobility solutions, and its TDX series of power wheelchairs exemplifies the company's commitment to innovation, comfort, and user-centric design. The TDX 4, TDX 3 SE, TDX 3, and TDX 5 are prominent models within this series, each equipped with cutting-edge features and technologies that cater to the diverse needs of users.

The TDX 4 is designed for superior maneuverability and driving performance. It boasts a unique Mid-Wheel Drive technology, which ensures that the chair can pivot in place with ease, allowing users to navigate tight spaces effortlessly. The TDX 4 is equipped with a highly adjustable seating system and a modular design that allows for customization based on user preferences and needs. With an active anti-tip system, the TDX 4 ensures stability on slopes and uneven terrains, enhancing user safety.

Next in the lineup is the TDX 3 SE, which emphasizes enhanced seating and suspension systems. Users can enjoy a smooth ride thanks to its advanced suspension that absorbs shocks and vibrations. The TDX 3 SE offers flexible seating options, including tilt, recline, and elevating legrests, allowing for optimal positioning and comfort. With a robust driving range, the TDX 3 SE is perfect for individuals looking to explore their surroundings while ensuring adequate support and comfort.

The TDX 3, another noteworthy entry, incorporates many of the features found in its siblings but is tailored for those who need a more straightforward approach. This model is lightweight yet durable, making it easy to transport and manage. With a focus on reliability and ease of use, the TDX 3 is an excellent choice for individuals who prioritize practicality without compromising on quality.

Finally, the TDX 5 stands out with its advanced technological integration. It features smart technology that allows for intuitive control and customization. The control systems are designed to be user-friendly, accommodating those with varying levels of dexterity. Advanced battery technology ensures long-lasting performance, while the ergonomic design promotes comfort during extended use.

In conclusion, the Invacare TDX series—including the TDX 4, TDX 3 SE, TDX 3, and TDX 5—offers a range of features that cater to different mobility needs. With their focus on maneuverability, comfort, and technological innovation, these power wheelchairs empower users to regain independence and enjoy a more active lifestyle.
Top Page Image Contents