Grizzly G0467, G470, G0468, G0465 instruction manual Fixing Air Leaks, To find air leaks

Page 22

3.Inspect the O-ring and diaphragm (Figure 14) for damage and dirt.

Diaphragm

O-ring

Figure 14. Check valve diaphragm and

spring.

4.Replace any damaged parts and clean any dirt off of the diaphragm and O- ring.

5.Re-assemble the check valve. Make sure the diaphragm presses squarely against the air supply tube opening.

Fixing Air Leaks

Air leaks will cause low air output and increase the time the compressor must run.

To find air leaks:

1.Turn the compressor OFF when the tank is fully pressurized and unplug the compressor.

2.Listen for the sound of air to find fittings that may be leaking.

3.Spray the suspected air leak with a soap and water solution. If you see air bubbles, you have found your leak.

To fix air leaking around fitting threads:

1.Unplug the air compressor and drain all the air from the tank.

2.Unscrew the fitting that is leaking. Clean and wrap teflon tape and/or spread pipe dope on the threads.

3.Re-install the fitting to the compressor.

To fix air leaking through a valve:

1.Unplug the air compressor and drain all the air from the tank.

2.Remove the valve, clean it thoroughly, then re-install with teflon tape and/or pipe dope.

3.If the valve continues to leak, replace it with a new valve.

-20-	Model G0464/G0465/G0467/G0468/G0470 Air Compressors

Image 22

Contents AIR Compressor Page Table of Contents Introduction Foreword Contact InfoMachine Data Sheet Safety Mation about proper operation of the equipmentModel G0464/G0465/G0467/G0468/G0470 Air Compressors Additional Safety Instructions For Air Compressors Circuit Requirements 110V OperationGrounding Unpacking SET UPAssembly To assemble the air compressorPlacement Operations Operation Safety StartingTo start the air compressor Line Pressure Regulation To control the air supply to your toolConnecting Tools To connect air tools to your air com- pressorWhen storing your air compressor, fol- low these guidelines StorageMaintenance ScheduleDraining Tank Pressure Safety ValveTo check the pressure safety valve To drain the tankTroubleshooting ServiceSymptom Possible Cause Possible Solution See Changing Oil Check ValveFixing Air Leaks To find air leaksPressure Switch Pressure switch coverG0464 Parts Breakdown G0464 Parts List DescriptionG0465 Parts Breakdown G0465 Parts List G0467 Parts Breakdown G0467 Parts List REF DescriptionG0468 Parts Breakdown G0468 Parts List G0470 Parts Breakdown G0470 Parts List Warranty and Returns Warranty Card Name Street CityStateZip BOX BELLINGHAM, WA