Hobart Welding Products OM-925 217 694A manual Changing Drive Roll Or Wire Inlet Guide

Page 29

6-4. Changing Drive Roll Or Wire Inlet Guide

1

3

2

4

Tools Needed:

1Inlet Wire Guide Securing Screw

2Inlet Wire Guide

Loosen screw. Slide tip as close to drive rolls as possible without touching. Tighten screw.

3 Drive Roll

The drive roll consists of two differ- ent sized grooves. The stamped markings on the end surface of the drive roll refers to the groove on the opposite side of the drive roll. The groove closest to the motor shaft is the proper groove to thread (see Section 4-10).

4 Retaining Pin

To secure drive roll, locate open slot and push drive roll completely over retaining pin, then rotate drive roll (1/4 turn) to closed slot.

.030/.035 Groove

Stamped .024

.023/.025 Groove

Stamped .030/.035

Ref. 803 714-A

6-5. Replacing Gun Contact Tip

Y Turn Off power before replacing contact tip.

1 Nozzle

2 Contact Tip

Cut off welding wire at contact tip.

Remove nozzle.

Remove contact tip and install new contact tip. Reinstall nozzle.

2

1

Tools Needed:

Ref. 802 399-A

Return To Table Of Contents

OM-925 Page 25

Image 29
Contents Description OM-925Processes From Hobart to You Table of Contents Options and Accessories Warranty Marks a special safety message Symbol UsageArc Welding Hazards Electric Shock can killWelding can cause fire or explosion ARC Rays can burn eyes and skinFlying Metal can injure eyes Buildup of GAS can injure or killCalifornia Proposition 65 Warnings About Pacemakers Principal Safety StandardsEMF Information − Consignes DE Sécurité − À Lire Avant Utilisation Identifie un message de sécurité particulierLES Particules Projetées peu- vent blesser les yeux LE Soudage peut causer un incen- die ou une explosionLES Pièces Chaudes peuvent cau- ser des brûlures graves LE Bruit peut affecter l’ouïeLA Chute DE L’APPAREIL peut blesser Risque D’INCENDIE OU D’EXPLO’EMPLOI Excessif peut Faire LES Pièces Mobiles peuvent cau- ser des blessuresConsignes relatives aux stimulateurs cardiaques Principales normes de sécuritéInformation sur les champs électromagnétiques VAC Model − SpecificationsSpecifications Amperes Duty Cycle And OverheatingOutput Duty Cycle % VAC Model Output AmperesVoltage Volt-Ampere CurvesInstalling Welding Gun Installing Work Clamp − InstallationChanging Polarity Process/Polarity TableInstalling Gas Supply Is required = GND/PE Do not move or operate unit where it could tipInstalling Wire Spool And Adjusting Hub Tension Electrical Service Guide For 230 VAC ModelHold wire tightly to keep it From unraveling Threading Welding WireControls − OperationSteel Weld Parameter Chart For 115 VAC ModelInch 20 ga 18 ga 16 ga 11 ga Weld Parameter Chart For 230 VAC Model 18 ga 16 ga 11 ga 048 060 Inch Wire Welding PackageRoutine Maintenance − Maintenance &TROUBLESHOOTINGDisconnect power before maintaining Overload Protection Drive Motor ProtectionReplacing Gun Contact Tip Changing Drive Roll Or Wire Inlet GuideTurn Off power before replacing contact tip To Reassemble Gun Cleaning Or Replacing Gun LinerDisconnect gun from unit Replacing Switch And/Or Head Tube Trouble Remedy Troubleshooting TableCircuit Diagram For 115 VAC Model − Electrical DiagramCircuit Diagram For 230 VAC Model Typical MIG Process Connections − MIG Welding Gmaw GuidelinesWire Size Amperage Range Typical MIG Process Control SettingsThickness to Amperage a Select VoltageHolding And Positioning Welding Gun Conditions That Affect Weld Bead Shape Gun Movement During Welding Poor Weld Bead CharacteristicsGood Weld Bead Characteristics Troubleshooting − Porosity Troubleshooting − Excessive SpatterTroubleshooting − Excessive Penetration Possible Causes Corrective ActionsTroubleshooting − Burn-Through Troubleshooting − Lack Of PenetrationTroubleshooting − Incomplete Fusion Troubleshooting − Distortion Troubleshooting − Waviness Of BeadApplication Troubleshooting Guide For Semiautomatic Welding EquipmentCommon MIG Shielding Gases Welding arc not stable Wire slipping in drive rolls Return To Table Of Contents Main Assembly − Parts ListDia Part H-10 Gun 195 Optional Drive RollsOptions Page Support ServiceHobart Welding Products Contact your Distributor for