Owner's Manual
Battery
Charger
Model:
Fully Automatic Battery Charger
For 12 Volt Marine Deep Cycle &
Automotive Batteries
–Save–
Important Safety Instructions
Read Rules for Safe Operation and Instructions Carefully
Working in vicinity of a
WARNING: Handling the cord on this product or cords associated with accessories sold with this product, will expose you to lead, a chemical known to the State of California to cause cancer and birth defects or other reproductive harm. Wash hands after handling.
GENERAL BATTERY SAFETY
1.Before you use your battery charger, be sure to read all instructions and cautions printed on:
•Battery Charger
•Battery
•Vehicle or unit using battery
2.Use battery charger on LEAD ACID type rechargeable bat- teries only, such as used in autos, trucks, tractors, airplanes, vans, RVs, trolling motors, etc. Charger is not intended to supply power to
WARNING: Do not use battery charger for charging dry- cell batteries that are commonly used with home appliances. These batteries may burst and cause injury to persons and damage to property.
3.Use only attachments recommended or sold by manufac- turer. Use of
4.When disconnecting the battery charger, pull by the plug not by the cord. Pulling on the cord may cause damage to cord or plug.
5.Locate battery power cord so it cannot be stepped on, tripped over, or subjected to damage or stress.
6.Do not operate charger with damaged cord or plug. Have cord replaced immediately.
7.Do not operate charger if it has received a sharp blow, been dropped, or otherwise damaged in any way. Take it to a qualified professional for inspection and repair.
8.Do not disassemble charger. Take it to a qualified profes- sional when service or repair is required. Incorrect reas- sembly may result in electric shock or fire.
9.To reduce risk of electric shock, unplug charger from outlet before attempting any maintenance or cleaning.
10.Do not use an extension cord unless absolutely necessary. Use of an improper extension cord could result in fire or
electric shock. If an extension cord must be used, make sure that:
•Pins on plug of extension cord are the same number, size, and shape as those of plug on charger.
•Extension cord is properly wired and in good electrical condition.
•Wire size is large enough for AC ampere rating of charger, as specified below:
Length of cord (feet): | 25 | 50 | 100 | 150 |
AWG size of cord: | 18 | 18 | 16 | 14 |
11.Always charge battery in a well ventilated area.
NEVER operate in a
WARNING: Risk of explosive gas.
12.Locate charger as far away from battery as DC charger cables permit.
13.Do not expose charger to rain or snow.
14.NEVER charge a frozen battery. If battery fluid (electrolyte) is frozen, bring into a warm area to thaw before charging.
15.NEVER allow battery acid to drip on charger when reading specific gravity or filling battery.
16.NEVER set a battery on top of charger.
17.NEVER place charger directly above battery being charged. Gases from battery will corrode and damage charger.
18.NEVER touch the battery clips together when the charger is energized.
19.NEVER crank engine with charger attached to battery. WARNING: Battery chargers get hot during operation and must have proper ventilation. Air needs to flow around en- tire charger. Do not set on flammable items like carpeting, upholstery, paper, cardboard, etc. Will damage leather and melt plastic and rubber.
SCHUMACHER ELECTRIC CORPORATION
801 BUSINESS CENTER DRIVE • MOUNT PROSPECT, ILLINOIS 60056-2179
Send Warranty Product Repairs to: 1025 E. Thompson, Hoopeston, IL
Call Customer Service if you have questions:
1