Roberts Gorden CGTH-30, CGTH-50, CGTH-40 service manual Roberts-Gordon, LLC

TABLE OF CONTENTS
SECTION 1: Before You Begin		1
1.1 Read This Manual		1
1.2 Questions, Comments or Suggestions		1
SECTION 2: Heater Safety		2
SECTION 3: Introduction		3
3.1	About Roberts-Gordon	3
3.2	About the Heater	3
3.3	Unpacking the Heater	3
3.4	Components Identification	4
3.5	Where Can the Heater Be Installed?	5
3.6	Where Can't the Heater Be Installed?	5
3.7	Installer's Responsibility	5
SECTION 4: Before Using The Heater		6
4.1	System Requirements	6
4.2	Gas Service Requirements:	6
4.3	Electrical Service Requirements	6
4.4	Venting Requirements	7
4.5	Non-Residential Installations	7
4.6	Heater Location	8
SECTION 5: Using The Heater		9
5.1	Required Safe Distances from Combustibles	9
5.2	Protective Grille	13
5.3	Rear Movable Hanger Limits	14
5.4	Operating Instructions	15
5.5	To Turn Off Gas To Heater	15
5.6	Sequence of Operation	16
5.7	Venting	16
SECTION 6: Caring For The Heater		18
6.1	Annual Inspection	18
6.2	Monthly Inspection	18
6.3	Maintenance Checklist	18
6.4	Basic Heater Care	19
6.5	Replacement Parts	19
SECTION 7: The ROBERTS GORDON® CARIBE® LIMITED
	Warranty	21

©2007 Roberts-Gordon, LLC

All rights reserved. No part of this work covered by the copyrights herein may be reproduced or copied in any form or by any means - graphic, electronic, or mechanical, including photocopying, recording, taping or information storage and retrieval systems - without the written permission of Roberts-Gordon, LLC.

Printed in the U.S.A.