United States Stove VFZC32N, VFZC32L installation manual VFZC32 Specifications

Page 4

WARNINGS/SAFETY INFORMATION CONTINUED

17.CARBON MONOXIDE POISONING: Early signs of carbon monoxide poisoning are similar to the flu with headaches, dizziness and/or nausea. If you have these signs, obtain fresh air immediately. Have the heater serviced as it may not be operating properly.

18.This vent-free gas fireplace is intended to be smokeless. If logs appear to smoke, turn off the heater and call a qualified service person. Initial burn off may cause slight smoke and odor during the first four hours of operation.

19.Input ratings are shown in BTU per hour and are for elevations up to 2,000 feet. For elevations above 2,000 feet, input ratings should be reduced 4 percent for each 1,000 feet above see level. Refer to the National Fuel Gas Code.

20.The fireplace and its individual shut off valve must be disconnected from the gas supply piping system during any pressure testing of that system at test pressures in excess of 1/2 psig (3.5 kPa).

21.The fireplace must be isolated from the gas supply piping system be closing its individual manual shutoff valve during any pressure testing of the gas supply piping system at test pressures equal to or less than 1/2 psig (3.5 kPa).

22.Do not use this gas fireplace if any part has been under water. Immediately call a qualified service technician to inspect the room heater and to replace any part of the control system and any gas control which has been under water.

VFZC32 SPECIFICATIONS

Natural Gas

 

 

Propane/LPG

 

 

Manifold Pressure Setting:

4" w.c.

Manifold Pressure Setting:

10" w.c.

Gas Inlet Pressure:

Maximum

10-1/2" w.c.

Gas Inlet Pressure:

Maximum

13" w.c.

 

Minimum

5" w.c.

 

Minimum

11" w.c.

 

 

Gas Rate

Number

Model Number

Type

Max BTU/Hr

Min BTU/Hr

of Burners

VFZC32N

Manual

30,000

8,000

2

VFZC32L

Manual

30,000

8,000

2

 

 

 

 

 

Controls - Main control has 4 positions:

1.OFF - All gas to the gas logs is shut off at the control

2.IGN - Piezo ignitor allows ignition of the pilot without the use of matches or batteries

3.PILOT - Valve position to light/maintain a standing pilot

4.ON - Gas flow to complete system, front burner ignition

Front Burner Control Knob - infinite control, rotate clockwise to minimum rate and counterclockwise to maximum rate.

Rear Burner Control Knob - Has 3 positions:

1.OFF - Gas to rear burner is shutoff at control

2.ON/MAX - Maximum gas flow to rear burner

3.MIN - Minimum gas flow rate to rear burner

4

Page 3 Page 5
Image 4
Page 3 Page 5
Contents Owners Operation and Installation Manual Do not use a blower insert Heat exchanger insert or other~WHAT to do if YOU Smell GAS Do not try to light any applianceTable of Contents Local CodesPage VFZC32 Specifications Firebox TOP View Firebox Front View Firebox Side View Locating Fireplace Product FeaturesAIR for Combustion and Ventilation Unusually Tight Construction Providing adequate ventilationConfined Space and Unconfined Space Determining if You Have a Confined or Unconfined Space Ventilation AIR Ventilation Air From Inside BuildingInstallation Installation ClearancesMantel Clearances for Conventional Installation Minimum Wall and Ceiling Clearances see FigureMantel Clearances for Built-in Installation Minimum Clearance to Wall and CeilingInstalling the Fireplace Screen Installing the Fireplace HoodInstalling the Firebrick Panels into the firebox GAS Connection Gas ConnectionGAS Pressure Check Flex Pipe Connected to controlMantel Installation Fireplace Installation Using Optional MantelInstalling Firebox on Hearth Base BUILT-IN Installation Built-in Fireplace InstallationHeight Front Width Depth Model # VFZC32Rough Opening for Installing in Corner Proper Installation Sequence LOG AssemblyLOG Positioning For Your Safety Read Before Lighting For Your SafetyOperating Instructions What to do if YOU Smell GASLighting Instructions Turn OFF GAS to ApplianceCleaning / Servicing Match Lighting InstructionsChecking Flame Appearance Pilot FlamePeriodic Cleaning Annual Cleaning/InspectionFlame Appearance FlamesParts Diagram and Parts List KEY Description PART# QTYGenerator Assembly Parts Diagram Generator Assembly Parts List KEY Description QTYVF32B Blower KIT, Wiring Diagram Installing the Optional VF32B Blower KitOptional Accessories Cabinet MantelHearth Base Face MantelBlower Accessory Wall Switch AccessoryRemote Control Accessory Aluminum Trim KitsHOW to Order Repair Parts Ussc

VFZC32L, VFZC32N specifications

The United States Stove Company has long been recognized for its quality heating solutions, and the VFZC32N and VFZC32L models exemplify this commitment to excellence. These freestanding vent-free zone heaters are designed to provide efficient and effective heating for residential spaces, showcasing advanced technologies and user-friendly features.

The VFZC32N model, with its natural gas configuration, and the VFZC32L, which operates on propane, offer impressive heating capabilities. Both models can effectively heat areas up to 1,200 square feet, making them suitable for various room sizes in homes, garages, or workshops. They feature a clean, modern design that complements contemporary and traditional decor alike, with a sleek finish that enhances any interior space.

One of the standout characteristics of these heaters is their high-efficiency rating. With a 99% thermal efficiency, the VFZC32 series maximizes heat output while minimizing fuel consumption. This efficiency not only leads to lower energy bills but also results in a more eco-friendly heating solution. The vent-free technology allows these units to operate without the need for venting, simplifying the installation process and providing more flexibility in placement.

Safety features are a priority in the VFZC32N and VFZC32L models. Both heaters come equipped with an oxygen depletion sensor (ODS) that automatically shuts off the heater if oxygen levels fall below a safe threshold. Additionally, the built-in thermostat ensures optimal temperature control, allowing for consistent and comfortable heat throughout the space.

User convenience is further enhanced by the electronic ignition system, which provides hassle-free startups without the need for manual lighting. The adjustable flame height allows users to customize the heat output to suit their specific needs, while the easy-access control panel ensures straightforward operation.

In conclusion, the United States Stove VFZC32N and VFZC32L models represent an excellent choice for those seeking reliable and efficient heating solutions. With their impressive efficiency, modern design, and advanced safety features, these vent-free heaters make it easier than ever to enjoy warmth and comfort at home. Whether you are looking to heat a single room or a larger space, the VFZC32 series is certainly worth considering for your heating needs.
Top Page Image Contents