Maytag HR652DJRT, HR652SJRT, HR682SJRT, HR666DJRT, HR666SJRT, HR682DJRT Safety Instructions cont’d

Page 3

Safety Instructions (cont’d)

WARNING

WATER HEATERS EQUIPPED FOR ONE VOLTAGE ONLY: This water heater is equipped for one type voltage only. Check the rating plate near the bottom access panel for the correct voltage. DO NOT use this water heater with any voltage other than the one shown on the model rating plate. Failure to use the correct voltage can cause problems which can result in DEATH, SERIOUS BODILY INJURY, OR PROPERTY DAMAGE. If you have any questions or doubts consult your electric company.

WARNING

HYDROGEN GAS: Hydrogen gas can be produced in a hot water system that has not been used for a long period of time (generally two weeks or more). Hydrogen gas is extremely flammable and explosive. To prevent the possibility of injury under these conditions, we recommend the hot water faucet be opened for several minutes at the kitchen sink before any electrical appliances which are connected to the hot water system are used (such as a dishwasher or washing machine). If hydrogen gas is present, there will probably be an unusual sound similar to air escaping through the pipe as the hot water faucet is opened. There must be no smoking or open flame near the faucet at the time it is open.

CAUTION

WATER HEATERS EVENTUALLY LEAK: Installation of the water heater must be accomplished in such a manner that if the tank or any connections should leak, the flow of water will not cause damage to the structure. For this reason, it is not advisable to install the water heater in an attic or upper floor. When such locations cannot be avoided, a suitable drain pan should be installed under the water heater. Drain pans are available at your local hardware store. Such a drain pan must have a minimum diameter of at least 13/4 inches greater than the water heater diameter and must be piped to an adequate drain.

CAUTION

Never use this water heater unless it is completely full of water. To prevent damage to the tank and heating element, the tank must be filled with water. Water must flow from the hot water faucet before turning “ON” power.

3

Page 2 Page 4
Image 3
Page 2 Page 4
Contents Series Six Safety Instructions Safety Instructions cont’d Table of Contents Product Specifications Customer In formationHR630SJRT HR630DJRT HR630SJLS HR630DJLS HR640SJRT HR640DJRT HR640SJRS HR640DJRS HR640SJLS HR640DJLS HR652SJRT HR652DJRT HR650SJRS HR650DJRS HR650SJLSHR650DJLS HR666SJRT HR666DJRT HR682SJRT HR682DJRT HR6120SJRT HR6120DJRT Product SpecificationsTools Accessories and Tools NeededAccessories Additional Tools Needed When Sweat SolderingRemoving the Old Water Heater Installation InstructionsInstructions for Installation cont’d Typical InstallationLocating The New Water Heater Valve and Pipe Insulation Water PipingTemperature-Pressure Relief Valve Wiring Diagrams Standard Wiring for Single Element 240 VoltFilling the Water Heater Wiring Model Rating Plate Installation ChecklistThermostats Service and MaintenanceTemperature Regulation Temperature SettingsAnode Rod Inspection Service and Maintenance cont’dThermostat Adjustments Temperature-Pressure Relief Valve OperationDraining Thermostat Removal/ReplacementThermostat Removal cont’d Element Cleaning ReplacementLower Thermostat Element Cleaning Replacement cont’d Drain Valve Washer ReplacementService Troubleshooting Start Up ConditionsOperational Conditions Not Enough or no HOT Water Troubleshooting cont’dLeakage Checkpoints Page Repair Parts List Repair Parts List cont’d This is a Repair Parts LIST, not a Packing ListSee Repair Parts List cont’d See Note on Repair Parts List cont’d Model Number Serial Number Part Description Repair Parts List cont’d Repair Parts List cont’d Maytag State Page Limited Tank Warranty Against Leaks WarrantyFull ONE Year Warranty Limited Parts Warranty
Top Page Image Contents