Multiquip QPT305SLT, QP305SLT manual Troubleshooting Engine

Page 25

 

troubleshooting

 

 

 

 

 

 

 

Troubleshooting (Engine)

 

Symptom

Possible Problem

Solution

 

 

 

 

Spark plug bridging?

Check gap, insulation or replace spark plug.

 

 

 

 

Carbon deposit on spark plug?

Clean or replace spark plug.

 

 

 

 

Short circuit due to deficient spark plug

Check spark plug insulation, replace if worn.

 

insulation?

 

 

 

Improper spark plug gap?

Set to proper gap.

 

Fuel reaching carburetor?

Check fuel line.

 

Water in fuel tank?

Flush or replace fuel tank.

 

Fuel filter clogged?

Replace fuel filter.

Difficult to start, fuel is available, but no spark

Stuck carburetor?

Check float mechanism.

Spark plug is red?

Check transistor ignition unit.

at spark plug.

 

 

If insufficient compression, repair or replace

 

Spark plug is bluish white?

engine. If injected air leaking, correct leak. If

 

 

carburetor jets clogged, clean carburetor.

 

 

 

 

 

Check transistor ignition unit is broken, and

 

No spark present at tip of spark plug?

replace defective unit. Check if voltage cord

 

cracked or broken and replace. Check if

 

 

 

 

spark plug if fouled and replace.

 

 

 

 

No oil?

Add oil as required.

 

 

 

 

Oil pressure alarm lamp blinks upon starting?

Check automatic shutdown circuit, "oil

 

(if applicable)

sensor". (if applicable)

 

ON/OFF switch is shorted?

Check switch wiring, replace switch.

Difficult to start, fuel is available, and spark is

Ignition coil defective?

Replace ignition coil.

Improper spark gap, points dirty?

Set correct spark gap and clean points.

present at the spark plug.

Condenser insulation worn or short circuiting?

Replace condenser.

 

 

Spark plug wire broken or short circuiting?

Replace defective spark plug wiring.

 

Wrong fuel type?

Flush fuel system, and replace with correct

 

type of fuel.

 

 

Difficult to start, fuel is available, spark is

 

 

Water or dust in fuel system?

Flush fuel system.

present and compression is normal.

 

 

Air cleaner dirty?

Clean or replace air cleaner.

 

 

 

 

 

Choke open?

Close choke.

 

 

 

 

Suction/exhaust valve stuck or protruded?

Reseat valves.

 

 

 

 

Piston ring and/or cylinder worn?

Replace piston rings and/or piston.

Difficult to start, fuel is available, spark is

 

 

Cylinder head and/or spark plug not tightened

Torque cylinder head bolts and spark plug.

present and compression is low.

properly?

 

 

Head gasket and/or spark plug gasket

Replace head and spark plug gaskets.

 

damaged?

 

 

 

No fuel in fuel tank?

Fill with correct type of fuel.

 

Fuel cock does not open properly?

Apply lubricant to loosen fuel cock lever,

 

replace if necessary.

No fuel present at carburetor.

 

Fuel filter/lines clogged?

Replace fuel filter.

 

 

Fuel tank cap breather hole clogged?

Clean or replace fuel tank cap.

 

Air in fuel line?

Bleed fuel line.

QP305SLT/QPT305SLT CENTRIFUGAL PUMP • operation and parts manual — rev. #1 (10/11/10) — page 25

Image 25
Contents Model QP305SLT/QPT305SLT Proposition 65 warning Page QP305SLT/QPT305SLT Table of ContentsChoose from three easy options Safety Information General Safety Always ensure pump is on level ground before use Safety InformationSafety Information SPECIFICATIONS/DIMENSIONS Pump Specifications Engine General information Drain Plug Remove this plug to drain water from the pump Pump componentsINITIAL Servicing Basic engineBefore Starting InspectionEngine Oil Check Fuel CheckHoses and Clamps SET-UPStarting the Engine Honda OperationEmergency Shutdown Stopping the Engine Normal ShutdownAdjusting Impeller Clearance Maintenance pumpPump Vacuum Test Maintenance pump Engine Maintenance Maintenance engineDaily MaintenanceWeekly Pump Storage Preparation for long-term storageSymptom Possible Cause Solution TroubleshootingTroubleshooting Engine Air cleaner dirty? Clean or replace air cleaner Page No. Column Explanation of Code in Remarks ColumnPaRT No. Column QTY. ColumnSuggested Spare Parts Pump Assembly Suction COVER, NPT CasingCheck Valve QP305SLT onlyPump Assembly Not Sold Separately Spring Washer M8Includes Items W/ $ NUT M8Honda GX340K1PKT2/GX340U1PKT2 air cleaner assy GROMMET, AIR Cleaner COVER, AIR CleanerCOLLAR, AIR Cleaner Collar B, AIR CleanerHonda GX340K1PKT2/GX340U1PKT2 camshaft assy ROD, Push SPRING, Weight ReturnARM, Valve Rocker LIFTER, ValveHonda GX340K1PKT2/GX340U1PKT2 carburetor assy Gasket SET PLATE, Lever SettingValve SET, Float Float SETHonda GX340K1PKT2/GX340U1PKT2 control assy ARM, Governor SPRING, Control AdjustingROD, Governor SPRING, GovernorHonda GX340K1PKT2/GX340U1PKT2 crankcase cover assy HOLDER, Governor Weight WEIGHT, GovernorPIN, Governor Weight GASKET, Case CoverHonda GX340K1PKT2/GX340U1PKT2 crankshaft assy Crankshaft P-TYPE WEIGHT, BalancerHonda GX340K1PKT2/GX340U1PKT2 cylinder barrel assy SHAFT, Governor ARM Switch ASSEMBLY, OIL LevelSUB- Harness BOLT,FLANGE 6X12 CT200Honda GX340K1PKT2/GX340U1PKT2 cylinder head assy CLIP, Valve Guide Cylinder HeadGASKET, Cylinder Head COVER, HeadHonda GX340K1PKT2/GX340U1PKT2 fan cover assy CLIP, Tube CLIP, Wire HarnessCOVER, FAN *R8* Bright RED COVER, FAN *NH1Honda GX340K1PKT2/GX340U1PKT2 flywheel assy PULLEY, Starter FAN, CoolingFlywheel NUT, Special 16MMHonda GX340K1PKT2/GX340U1PKT2 fuel tank assy JOINT, Fuel Tank RUBBER, Supporter 107MMTANK, Fuel Black TANK, Fuel *NH31Honda GX340K1PKT2/GX340U1PKT2 ignition coil assy GROMMET, Wire Coil ASSEMBLY, IgnitionWIRE, Stop Switch 430MM CLIP, HarnessHonda GX340K1PKT2/GX340U1PKT2 muffler assy PROTECTOR, R. Muffler MufflerPROTECTOR, L. Muffler PIPE, EXHonda GX340K1PKT2/GX340U1PKT2 piston assy Ring SET, PISTON- Standard BOLT, Connecting RODPISTON- Standard PISTON- OS 0.25 OptionalHonda GX340K1PKT2/GX340U1PKT2 recoil starter assy PULLEY, Recoil Starter CASE, Recoil Sarter *R280RATCHET, Starter SPRING, FrictionHonda GX340K1PKT2/GX340U1PKT2 Labels Assy MARK, Choke External EmblemMARK, Choke Gray MARK, OIL Alert EFreight Policy Terms and Conditions of Sale PartsPage HERE’S HOW to GET Help

QPT305SLT, QP305SLT specifications

The Multiquip QPT305SLT is a state-of-the-art portable generator designed for construction sites, outdoor events, and emergency power needs. Known for its robust performance and reliability, the QPT305SLT is a standout choice for those requiring a dependable power source in demanding environments.

One of the main features of the QPT305SLT is its powerful engine. Equipped with a high-efficiency, 305 cc engine, the generator provides an output of up to 3,000 watts, making it suitable for various applications, from powering tools to providing backup energy during outages. The engine's design focuses on fuel efficiency and low emissions, aligning with current environmental standards while ensuring long operating times between refueling.

In terms of technology, the QPT305SLT incorporates advanced noise reduction systems, allowing it to operate at lower decibel levels, making it ideal for use in residential areas or noise-sensitive environments. An intelligent monitor system provides real-time data on voltage and frequency, ensuring that users are always aware of their power situation and can make informed decisions about their energy needs.

The QPT305SLT also features an integrated inverter, which helps deliver clean and stable power suitable for sensitive electronic devices. This feature is particularly beneficial for users needing to power computers, communication equipment, or medical devices. The inverter technology not only enhances the quality of the output power but also improves fuel efficiency.

Durability is another characteristic that sets the QPT305SLT apart. The generator is built with a heavy-duty frame and protective features to withstand the rigors of outdoor use. Additionally, it includes a maintenance-friendly design, making service checks and repairs straightforward.

Portability is a significant advantage of the QPT305SLT. With a lightweight construction and ergonomic handle design, moving the generator from one location to another is easy, making it an excellent choice for contractors and event organizers alike.

Overall, the Multiquip QPT305SLT combines power, efficiency, and user-friendly features, establishing itself as a reliable option for those in need of versatile and portable power solutions. Whether for job sites, outdoor activities, or emergency backups, this generator is engineered to meet the highest standards of performance and durability.