Monessen Hearth DLX28, GLX28, GLX24, GLX18, DLX18 MILLI-VOLT Control Lighting Instructions, Pilot

Page 29

OPERATING INSTRUCTIONS

MILLI-VOLT CONTROL LIGHTING INSTRUCTIONS

1.STOP! Read the safety information label.

2.Make sure the manual shutoff valve is fully open.

3.This gas log set is equipped with an ignition device (piezo) which automatically lights the pilot. If piezo ignitor does not light the pilot, refer to instructions for “MATCH LIGHTING INSTRUCTIONS”, page 30.

4.Turn gas control knob clockwise to the OFF position, set the thermostat to the lowest setting and turn ON/OFF switch to OFF position.

5.Wait (5) minutes to clear out any gas. Then smell for gas, including near the floor. If you smell gas, STOP! Follow "B" in the safety information label. If you don't smell gas, go to next step.

6.From OFF position, turn the gas control knob counterclockwise to IGN position. Push in control knob for 5 seconds.

7.With the control knob pushed in, push in and release the piezo ignitor button to light the pilot.

8.Continue pushing the control knob in for an additional 60 seconds to prevent the flame detector from shutting off the gas while the probe is warming up. Release the control knob.

9.Turn gas control knob counterclockwise to the ON position.

10.After the pilot has been lit for one minute, the burners can be turned on. Turn the ON/OFF switch to ON position or adjust thermostat to desired setting.

11.If the gas logs will not operate, follow the instructions “TO TURN OFF GAS TO APPLIANCE” below and call your service technician or gas supplier.

WARNING WARNING

Wait 30 seconds before readjusting the heater when the control knob has been turned down to a lower setting.

Gas

Control

Knob

Hi/Low Adjustment

Knob

Figure 34 - Pilot

Figure 35 - Control Knobs

Figure 36 - On/Off Switch

 

 

and Piezo

TO TURN OFF GAS TO HEATER

1.Turn control knob clockwise to OFF position to completely shut off the heater.

2.If applicable: Turn ON/OFF switch to OFF position and/or set thermostat (if present) to lowest setting.

3.If applicable: Turn off all electric power to the heater.

14D2099

29

Page 28 Page 30
Image 29
Page 28 Page 30
Contents What to do if YOU Smell GAS Models DLX18/GLX18 DLX24/GLX24 DLX28/GLX28Read and Save These Instructions Contents Owner Important Safety InformationInstaller From Make Sure YOU have Received ALL Parts Getting StartedPropane / LPG Product Features and SpecificationsNatural GAS Codes General Installation InformationAdequate Combustion and Ventilation AIR OFF IGN LOW/HIBTU/HR = L1 + L2 Ft x W Ft x H Ft x Fireplace and Hearth Dimensions Height of Restriction Minimum Depth of Fireplace/Firebox Placement in a Fireplace with a Restrictive BarrierSidewall & Ceiling Clearances Clearances and Height RequirementsClearances and Height Requirements Measuring Heat Resistant Material for Mantel Clearances and Height RequirmentsMinimum Mantel Clearance with No Hood DLX/GLX Minimum Mantel Clearance with No Hood DLX/GLX 24 Minimum Clearance above Combustible Flooring Floor ClearanceBefore Fully Installing the Unit Installing Vented ApplicationsBefore Installing the Appliance Damper Stop InstallationPlacing and Securing Appliance Installing Vented ApplicationsAssembly Procedure Gas Connection Connecting the GASManual Control Figure Checking GAS PressureConnecting Optional Wall Switch or Thermostat Electrical Wiring MILLI-VOLTComplete Millivolt System Check Connecting Remote ReceiverChecking System Operation Proper Sequence Oflog Installation LOG PlacementChecking the Pilot Flame Flame AppearanceMILLI-VOLT Control Manual Control and Thermostat ControlOperating Instructions Checking the Burner FlameWhat to do if YOU Smell GAS For Your Safety Read Before LightingOperating Instructions To Turn OFF GAS to Heater Manual Control Lighting InstructionsRotation of Control Knob Thermostatic Control Lighting InstructionsPilot MILLI-VOLT Control Lighting InstructionsMatch Lighting Instructions Cleaning and Servicing Replacement Parts List DLX/GLX 24/28 DLX/GLXLX Golden Oak Logs LX Aged Split Logs LX Weathered Oak Logs LX Chestnut Oak Logs Observed Problem Possible Cause Remedy TroubleshootingOne or both burners do not light 14D2099 14D2099 Basic Warranty Lifetime WarrantyFive Year Warranty

DLX18, GLX28, GLX18, GLX24, DLX28 specifications

Monessen Hearth is renowned for its innovative and aesthetically pleasing gas fireplaces, and models like the DLX28, GLX24, GLX18, GLX28, and DLX18 embody this excellence. These fireplaces are designed to elevate the ambiance of any space while providing reliable heating and energy efficiency.

The DLX series, including the DLX28 and DLX18, showcases a blend of traditional craftsmanship with modern performance. These models focus on user-friendly features, such as an easy-to-use remote control and touchscreen controls that allow homeowners to adjust settings with ease. The realistic flame presentation, enhanced by the vibrant, hand-painted log sets, offers a lifelike fire experience. The DLX series also prioritizes efficiency, with high AFUE ratings ensuring minimal energy waste.

In contrast, the GLX series, featuring the GLX24 and GLX28, is perfect for those looking to create a contemporary living space. These fireplaces provide a sleek aesthetic with clean lines and minimalistic designs, making them an ideal fit for modern interiors. The GLX models incorporate advanced technologies such as a glass ember bed and multiple flame height adjustments, providing a customizable ambiance tailored to any moment. Additionally, they offer the option of a direct vent installation, ensuring optimal ventilation while maintaining efficiency.

The GLX18 complements smaller spaces without sacrificing style or performance, making it ideal for compact homes or apartments. Like its larger counterparts, it utilizes advanced safety features, including a built-in oxygen depletion sensor for added peace of mind.

All Monessen Hearth fireplaces are equipped with robust safety systems, ensuring optimal performance and security for homeowners. These models are also designed for versatility, allowing them to be installed in various settings, from traditional brick fireplaces to contemporary wall-mounted configurations.

In summary, the Monessen Hearth DLX28, GLX24, GLX18, GLX28, and DLX18 fireplaces represent the pinnacle of comfort and technology, offering stylish designs, user-friendly features, and energy-efficient performance. Whether you prefer a classic or modern aesthetic, Monessen Hearth has a model to fit your unique style and heating needs, making them an excellent choice for any home.
Top Page Image Contents