Napoleon Fireplaces EF30G manual Table of contents, Introduction

2

table of contents

1.0	introduction		2
	1.1	warranty	3
	1.2	general instructions	4
	1.3	precautions	4
	1.4	listing approvals	5
	1.5	dimensions	6
	1.6	locating appliance	6
	1.7	unpacking and testing appliance	6

3.0	electrical requirements		7
	3.1	grounding appliance	7
	3.3	hardwire installation	8
3.0	installation		10
	3.1	minimum clearance to combustibles	10
	3.2	new construction or renovation	10
	3.3	installing the appliance	11
	3.4	glass ember installation	11
	3.5	thermostat and thermal sensor installation	12
4.0	framing		13
	4.1	HEARTH	14
	4.2	COLD CLIMATE INSTALLATION	14
	4.3	minimum mantel clearances	14
	4.4	finishing checklist	14
5.0	operating instructions		15
	5.1	remote control	16
6.0	maintenance		17
	6.1	flame generation bulb replacement	17
	6.2	ember bed bulb replacement	18
	6.3	cleaning	18
7.0	replacements		19
8.0	TROUBLESHOOTING		20

1.0 introduction

!WARNING

•Do not operate fireplace before reading and understanding operating instructions. Failure to operate fireplace according to operating instructions could cause fire or injury.

•Risk of burns. The fireplace should be turned off and cooled before servicing.

•Do not install damaged, incomplete or substitute components.

•Do not burn wood or other materials in this fireplace.

•Adults and especially children should be alerted to the hazards of high surface temperatures and should stay away to avoid burns or clothing ignition. Supervise young children when they are in the same room as the fireplace.

•Clothing or other flammable material should not be placed on or near the fireplace.

•Due to high temperatures, the fireplace should be located out of traffic and away from furniture and draperies.

•Ensure you have incorporated adequate safety measure to protect infants/toddlers from touching hot surfaces.

•Even after the fireplace is out, the glass and/or screen will remain hot for an extended period of time.

•Check with your local hearth specialty dealer for safety screens and hearth guards to protect children from hot surfaces. These screens and guards must be fastened to the floor.

•Any safety screen or guard removed for servicing must be replaced prior to operating the fireplace.

•It is imperative that the control compartments, circulating blower and its passageway in the fireplace and are kept clean. The fireplace should be inspected before use and at least annually by a qualified service person. More frequent cleaning may be required due to excessive lint from carpeting, bedding material, etc. The fireplace area must be kept clear and free from combustible materials, gasoline and other flammable vapors and liquids.

•Under no circumstances should this fireplace be modified.

•Do not use this fireplace if any part has been under water. Immediately call a qualified service technician to inspect the fireplace and to replace any part of the control system which has been under water.

•Do not operate the fireplace with the glass door removed, cracked or broken. Replacement of the glass should be done by a licensed or qualified service person.

•Do not strike or slam shut the fireplace glass door.

•Keep the packaging material out of reach of children and dispose of the material in a safe manner. As with all plastic bags, these are not toys and should be kept away from children and infants.

NOTE: Changes, other than editorial, are denoted by a vertical line in the margin.

tp - electric warning

W415-0760 / 12.19.08