Tecumseh OV195XA, OV195EA specifications California & US EPA Emission Control Warranty Statement

Page 30

CALIFORNIA & US EPA EMISSION CONTROL WARRANTY STATEMENT

The U. S. Environmental Protection Agency (“EPA”), the California Air Resources Board (“CARB”) and Tecumseh- Power Company are pleased to explain the Federal and California Emission Control Systems Warranty on your new small off-road engine. In California, new 1995 and later small off-road engines must be designed, built and equipped to meet the State’s stringent anti-smog stan- dards. In other states, new 1997 and later model year engines must be designed, built and equipped, at the time of sale, to meet the U.S. EPA regulations for small non-road engines. TecumsehPower Company will war- rant the emission control system on your small off-road engine for the periods of time listed below, provided there has been no abuse, neglect, unapproved modification, or improper maintenance of your small off-road engine.

Your emission control system may include parts such as the carburetor, air cleaner assembly, ignition system, exhaust system, crankcase breather assembly and, the evaporative control system. Also included may be the compression release system and other emission-related assemblies.

Where a warrantable condition exists, TecumsehPower Company will repair your small off-road engine at no cost to you for diagnosis, parts and labor.

MANUFACTURER’S EMISSION CONTROL SYSTEM WARRANTY COVERAGE

Emission control systems on 1995 and later model year California small off-road engines are warranted for two years as hereinafter noted. In other states, 1997 and later model year engines are also warranted for two years. If, during such warranty period, any emission-related part on your engine is defective in materials or workmanship, the part will be repaired or replaced by TecumsehPower Company.

OWNER’S WARRANTY RESPONSIBILITIES

As the small off-road engine owner, you are responsible for the performance of the required maintenance listed in your Operator’s Manual, but TecumsehPower Company will not deny warranty solely due to the lack of receipts or for your failure to provide written evidence of the perfor- mance of all scheduled maintenance.

As the small off-road engine owner, you should, however, be aware that TecumsehPower Company may deny you warranty coverage if your small off-road engine or a part thereof has failed due to abuse, neglect, improper main- tenance or unapproved modifications.

You are responsible for presenting your small off-road engine to a TecumsehPower Authorized Service Outlet

(any TecumsehPower Registered Service Dealer, TecumsehPower Authorized Service Distributor or TecumsehPower Central Warehouse Distributor) as soon as a problem exists. The warranty repairs should be completed in a reasonable amount of time, not to exceed 30 days.

Warranty service can be arranged by contacting either an Authorized TecumsehPower Servicing Dealer and/or TecumsehPower Company, c/o Service Manager, 900 North Street, Grafton, WI 53024-1499. Telephone 1-262- 377-2700 [or in USA/Canada call 1-800-558-5402].

IMPORTANT NOTE

This warranty statement explains your rights and obliga- tions under the Emission Control System Warranty (“ECS Warranty”) which is provided to you by TecumsehPower Company pursuant to California law. TecumsehPower Company also provides to original purchasers of new TecumsehPower engines the TecumsehPower Company Limited Warranties for New TecumsehPower Engines and Electronic Ignition Modules. The TecumsehPower Company Limited Warranties for New TecumsehPower Engines and Electronic Ignition Modules (“Tecumseh- Power Company Warranty”) are located on the back cover of the Operator’s Manual, enclosed with all new TecumsehPower engines. The ECS Warranty applies only to the emission control system of your new engine. To the extent that there is any conflict in terms between the ECS Warranty and the TecumsehPower Company Warranty, the ECS Warranty shall apply except in any cir- cumstances in which the TecumsehPower Company Warranty may provide a longer warranty period. Both the ECS Warranty and the TecumsehPower Company War- ranty describe important rights and obligations with respect to your new engine.

Warranty service can only be performed by a TecumsehPower Authorized Servicing Dealer. At the time of requesting warranty service, evidence must be presented of the date of sale to the original purchaser. The purchaser shall pay any charges for making service calls and/or for transport- ing the products to and from the place where the inspec- tion and/or warranty work is performed. The purchaser shall be responsible for any damage or loss incurred in connection with the transportation of any engine or any part(s) thereof submitted for inspection and/or warranty work.

If you have any questions regarding your warranty rights and responsibilities, you should contact TecumsehPower Company at 1-262-377-2700 or in USA/Canada call 1-800-558-5402.

Revised February 2008

IMPORTANT!

The Emission Regulations may be different for your country. The Emissions Control Warranty Statement is only applicable to engines with an emissions compliance statement and decal that references “Emissions Regulations”.

Page 28

Four-Cycle Engine • Vertical Crankshaft • Air-Cooled

181-1272-14

Page 29 Page 31
Image 30
Page 29 Page 31
Contents OV195EA/OV195XA Safety Definitions TecumsehPower Contact InformationAvoid Carbon Monoxide Poisoning General Safety PrecautionsAdult Supervision of Operation, Refueling and Maintenance Avoid Gasoline FiresAvoid Accidental Starts Do not Modify EngineAvoid Burns and Fire from Hot Surfaces Use Hearing ProtectionII. How to Get Service Engine Identification DecalTechnician’s Handbook Fuel III. Oil and Fuel SpecificationsOil Fuel Component PercentageFilling Oil Sump IV. Before Starting Your EngineChecking Oil Level Fill Between ULL Full and ADD MarksFilling Fuel Tank Front View Bottom ViewPrimer Bulb Only Starting Your EngineEngines with Electric Starters If your engine has Go toII. Choke Only Start/Choke Control PositionsTemperatures Above 40F 5C Temperatures Below 40F 5CIII. Primer Bulb and Choke Engines with Recoil Starters Engines with Recoil StartersPrimer Bulb Vent Hole Typical Engine Symbols Slow Position RUN Range Fast PositionVII. Maintenance VI. Stopping Your Engine and Short-Term StorageChecking and Changing Oil Typical Spark Connection Removing Debris from Engine Spark PlugServicing Paper Filter Cleaning/Replacing Air CleanerII. Removal and Installation of Air Cleaner Paper Filter Slots Flange Tabs CoverCarburetor AdjustmentsVIII. Transporting Your Engine Engine SpeedIX. Storing Your Engine Short-Term/Seasonal StorageExtended Storage IV. Battery II. Oil Cylinder BoreIII. Oil Procedure XI. Maintenance IntervalsMaintenance Intervals Preventing Forest, Brush and Grass FiresEvery 25 Hours or 3 Months 1. Change Oil Every 200 Hours or Seasonally 1. Replace Spark Plug Four-Cycle Engine Vertical Crankshaft Air-Cooled Four-Cycle Engine Vertical Crankshaft Air-Cooled Four-Cycle Engine Vertical Crankshaft Air-Cooled Four-Cycle Engine Vertical Crankshaft Air-Cooled Four-Cycle Engine Vertical Crankshaft Air-Cooled California & US EPA Emission Control Warranty Statement Emission Control System Warranty XII. Warranty Information Consumer USE Commercial USE

OV195XA, OV195EA specifications

The Tecumseh OV195XA and OV195EA engines are notable members of Tecumseh's extensive lineup of reliable and efficient power products. Designed primarily for outdoor power equipment, these engines cater to diverse applications including lawn mowers, generators, and other small machinery. Both models are characterized by their compact design, robust performance, and user-friendly features.

One of the standout features of the OV195XA and OV195EA is their powerful 195cc displacement, which delivers a significant amount of torque for heavy-duty applications. The engines are equipped with a reliable overhead valve (OHV) configuration, enabling better combustion efficiency and improved power output. This design not only contributes to higher performance but also leads to enhanced fuel economy, an essential aspect for users looking to maximize efficiency.

These engines also incorporate a lightweight aluminum die-cast crankcase, which reduces overall weight without compromising strength. This material choice provides durability while making the engines easier to handle and install. The dual-element air cleaner enhances the engines' filtration systems, ensuring cleaner air intake and prolonging engine life by minimizing wear and tear.

The Tecumseh OV195XA and OV195EA engines are engineered with a focus on ease of maintenance. They feature an integrated fuel tank, allowing for quick and convenient refueling. Additionally, the side-access oil drain simplifies oil changes, making it easier for operators to maintain the engines without requiring specialized tools.

Another important aspect of these engines is their low vibration and noise levels. Designed with advanced technology that minimizes both sound and vibration, the OV195XA and OV195EA provide a more comfortable user experience, especially during prolonged operation.

In terms of starting, both engines offer easy recoil start mechanisms, ensuring that users can quickly get to work without the hassle of complicated starting procedures.

Overall, the Tecumseh OV195XA and OV195EA engines represent a blend of performance, durability, and user-friendly design. Their innovative features make them suitable for a broad range of applications, ensuring that they can meet the demands of both professional landscapers and DIY enthusiasts alike. With a focus on efficiency and reliability, these engines continue to uphold Tecumseh's legacy as a trusted manufacturer in the small engine market.
Top Page Image Contents