Tecumseh OV195EA, OV195XA specifications Emission Control System Warranty

Page 31

EMISSION CONTROL SYSTEM WARRANTY

Emission Control System Warranty (“ECS Warranty”) for 1995 and later model year California small off-road engines (for other states, 1997 and later model year engines):

A. APPLICABILITY: This warranty shall apply to 1995 and later model year California small off-road engines (for other states, 1997 and later model year engines). The ECS Warranty Period shall begin on the date the new engine or equipment is delivered to its original, end-use purchaser, and shall continue for 24 consecutive months thereafter.

B. GENERAL EMISSIONS WARRANTY COVERAGE: TecumsehPower Company warrants to the original, end-use purchaser of the new engine or equipment and to each subsequent purchaser that each of its small off-road engines is:

1.Designed, built and equipped so as to conform with all applicable regulations adopted by the Air Resources Board pursuant to its authority in Chapters 1 and 2, Part 5, Division 26 of the Health and Safety Code, and

2.Free from defects in materials and workmanship which, at any time during the ECS Warranty Period, will cause a warranted emissions-related part to fail to be identical in all material respects to the part as described in the engine manufacturer’s application for certification.

C.THE ECS WARRANTY ONLY PERTAINS TO EMISSION- RELATED PARTS ON YOUR ENGINE AS FOLLOWS:

1.Any warranted, emissions-related parts which are not scheduled for replacement as required maintenance in the Operator’s Manual shall be warranted for the ECS Warranty Period. If any such part fails during the ECS Warranty Period, it shall be repaired or replaced by TecumsehPower Company according to Subsection 4 below. Any such part repaired or replaced under the ECS Warranty shall be warranted for any remainder of the ECS Warranty Period.

2.Any warranted, emissions-related part which is scheduled only for regular inspection as specified in the Operator’s Manual shall be warranted for the ECS Warranty Period. A statement in such written instructions to the effect of “repair or replace as necessary”, shall not reduce the ECS Warranty Period. Any such part repaired or replaced under the ECS Warranty shall be warranted for the remainder of the ECS Warranty Period.

3.Any warranted, emissions-related part which is scheduled for replacement as required maintenance in the Operator’s Manual, shall be warranted for the period of time prior to the first scheduled replacement point for that part. If the part fails prior to the first scheduled replacement, the part shall be repaired or replaced by TecumsehPower Company according to Subsection 4 below. Any such emissions-related part repaired or replaced under the ECS Warranty, shall be warranted for the remainder of the ECS Warranty Period prior to the first scheduled replacement point for such emissions-related part.

4.Repair or replacement of any warranted, emissions- related part under this ECS Warranty shall be performed at no charge to the owner at a TecumsehPower Authorized Service Outlet.

5.The owner shall not be charged for diagnostic labor which leads to the determination that a part covered by the ECS Warranty is in fact defective, provided that such diagnostic work is performed at a TecumsehPower Authorized Service Outlet.

6.TecumsehPower Company shall be liable for damages to other original engine components or approved modifications proximately caused by a failure under warranty of an emission-related part covered by the ECS Warranty.

7.Throughout the ECS Warranty Period, TecumsehPower Company shall maintain a supply of warranted emission- related parts sufficient to meet the expected demand for such emission-related parts.

8.Any TecumsehPower Company authorized and approved emission-related replacement part may be used in the performance of any ECS Warranty maintenance or repair and will be provided without charge to the owner. Such use shall not reduce TecumsehPower Company ECS Warranty obligations.

9.Unapproved add-on or modified parts may not be used to modify or repair a TecumsehPower engine. Such use voids this ECS Warranty and shall be sufficient grounds for disallowing an ECS Warranty claim. TecumsehPower Company shall not be liable hereunder for failures of any warranted parts of a TecumsehPower engine caused by the use of such an unapproved add-on or modified part.

EMISSION-RELATED PARTS INCLUDE THE FOLLOWING:

1.Carburetor Assembly including internal components:

a)Carburetor gaskets

b)Intake pipe

2.Air Cleaner Assembly including components:

a)Air filter element

3.Ignition System including components:

a)Spark plug

b)Ignition module

c)Flywheel assembly

4.Exhaust System including components:

a)Catalytic muffler (if so equipped)

b)Muffler gasket (if so equipped)

c)Exhaust manifold (if so equipped)

5.Crankcase Breather Assembly including components

a)Breather connection tube

6.Evaporative Control System including components:

a)Fuel line(s)

b)Fuel filter

c)Canister (if so equipped)

d)Fuel tank (if so equipped)

e)Fuel fill cap (if so equipped)

Revised February 2008

IMPORTANT!

The Emission Regulations may be different for your country. The Emissions Control Warranty Statement is only applicable to engines with an emissions compliance statement and decal that references “Emissions Regulations”.

181-1272-14

Four-Cycle Engine • Vertical Crankshaft • Air-Cooled

Page 29

Page 30 Page 32
Image 31
Page 30 Page 32
Contents OV195EA/OV195XA TecumsehPower Contact Information Safety DefinitionsAvoid Gasoline Fires General Safety PrecautionsAdult Supervision of Operation, Refueling and Maintenance Avoid Carbon Monoxide PoisoningUse Hearing Protection Do not Modify EngineAvoid Burns and Fire from Hot Surfaces Avoid Accidental StartsEngine Identification Decal II. How to Get ServiceTechnician’s Handbook Fuel Component Percentage III. Oil and Fuel SpecificationsOil FuelFill Between ULL Full and ADD Marks IV. Before Starting Your EngineChecking Oil Level Filling Oil SumpFront View Bottom View Filling Fuel TankIf your engine has Go to Starting Your EngineEngines with Electric Starters Primer Bulb OnlyStart/Choke Control Positions II. Choke OnlyTemperatures Below 40F 5C Temperatures Above 40F 5CIII. Primer Bulb and Choke Engines with Recoil Starters Engines with Recoil StartersPrimer Bulb Vent Hole Slow Position RUN Range Fast Position Typical Engine SymbolsVI. Stopping Your Engine and Short-Term Storage VII. MaintenanceChecking and Changing Oil Typical Spark Connection Spark Plug Removing Debris from EnginePaper Filter Slots Flange Tabs Cover Cleaning/Replacing Air CleanerII. Removal and Installation of Air Cleaner Servicing Paper FilterEngine Speed AdjustmentsVIII. Transporting Your Engine CarburetorShort-Term/Seasonal Storage IX. Storing Your EngineExtended Storage II. Oil Cylinder Bore IV. BatteryIII. Oil Preventing Forest, Brush and Grass Fires XI. Maintenance IntervalsMaintenance Intervals ProcedureEvery 25 Hours or 3 Months 1. Change Oil Every 200 Hours or Seasonally 1. Replace Spark Plug Four-Cycle Engine Vertical Crankshaft Air-Cooled Four-Cycle Engine Vertical Crankshaft Air-Cooled Four-Cycle Engine Vertical Crankshaft Air-Cooled Four-Cycle Engine Vertical Crankshaft Air-Cooled Four-Cycle Engine Vertical Crankshaft Air-Cooled California & US EPA Emission Control Warranty Statement Emission Control System Warranty Consumer USE Commercial USE XII. Warranty Information

OV195XA, OV195EA specifications

The Tecumseh OV195XA and OV195EA engines are notable members of Tecumseh's extensive lineup of reliable and efficient power products. Designed primarily for outdoor power equipment, these engines cater to diverse applications including lawn mowers, generators, and other small machinery. Both models are characterized by their compact design, robust performance, and user-friendly features.

One of the standout features of the OV195XA and OV195EA is their powerful 195cc displacement, which delivers a significant amount of torque for heavy-duty applications. The engines are equipped with a reliable overhead valve (OHV) configuration, enabling better combustion efficiency and improved power output. This design not only contributes to higher performance but also leads to enhanced fuel economy, an essential aspect for users looking to maximize efficiency.

These engines also incorporate a lightweight aluminum die-cast crankcase, which reduces overall weight without compromising strength. This material choice provides durability while making the engines easier to handle and install. The dual-element air cleaner enhances the engines' filtration systems, ensuring cleaner air intake and prolonging engine life by minimizing wear and tear.

The Tecumseh OV195XA and OV195EA engines are engineered with a focus on ease of maintenance. They feature an integrated fuel tank, allowing for quick and convenient refueling. Additionally, the side-access oil drain simplifies oil changes, making it easier for operators to maintain the engines without requiring specialized tools.

Another important aspect of these engines is their low vibration and noise levels. Designed with advanced technology that minimizes both sound and vibration, the OV195XA and OV195EA provide a more comfortable user experience, especially during prolonged operation.

In terms of starting, both engines offer easy recoil start mechanisms, ensuring that users can quickly get to work without the hassle of complicated starting procedures.

Overall, the Tecumseh OV195XA and OV195EA engines represent a blend of performance, durability, and user-friendly design. Their innovative features make them suitable for a broad range of applications, ensuring that they can meet the demands of both professional landscapers and DIY enthusiasts alike. With a focus on efficiency and reliability, these engines continue to uphold Tecumseh's legacy as a trusted manufacturer in the small engine market.
Top Page Image Contents